You are on page 1of 2

3-245-820-12(1)

A HOLD
i

Radio VOL*
ENTER

Cassette Player xSTOP


PRESET/TUNING
AA (R6) x 1 M +/–

TV/WB/FM AM NPLAY** SET


Operating instructions B C m FM/AM
For customers in the United States FWD
DIRY RADIO OFF
Owner’s Record
The model number is located on the bottom and the serial MODEs/d
number is located inside the cassette holder. Record these REV TV/WB (Weather)
MENU
numbers in the space provided below. Refer to them
whenever you call upon your Sony dealer regarding this * There is a tactile dot beside VOL on the main unit to show the
product. direction to turn up the volume.
Model No. WM-FX488 ** The button has a tactile dot.
Serial No.

To select playback mode Protecting your hearing—AVLS


Preparations Switch MODE to select the desired mode. (Automatic Volume Limiter System)
Press MENU repeatedly to set the cursor to AVLS in
To Insert Battery A
To play Select the display. Then press SET to show “ ”.
1 Slide open the battery compartment lid, and
WM-FX488 insert one size AA (R6) dry battery with
Both sides repeatedly s The maximum volume is kept down to protect your
ears.
Sony Corporation ©2002 Printed in Malaysia Both sides once from d
correct polarity.
the side facing the
Replace the battery with new one when " "
flashes in the display.
cassette holder (FWD)
Listening to the Radio
Printed using VOC (Volatile Organic Compound)-free
vegetable oil based ink. To select the tape direction 1 If the HOLD function is turned on, set the
HOLD switch in the opposite direction of the
Playing a Tape Switch DIRbB to select the desired direction.
G mark to unlock the controls. Make sure that
“WALKMAN” is a registered trademark of Sony Corporation to
represent Headphone Stereo products. 1 Insert a cassette. B the tape has stopped completely.
is a trademark of Sony Corporation. 2 Press NPLAY. Using Other Functions 2 Press TV/WB or FM/AM repeatedly to select
Adjust the volume with VOL. the desired band and to turn on the radio.
Locking the controls 3 Press PRESET/TUNING +/– to tune in to the
Product registration To Press Set the HOLD switch in the direction of the G mark desired station.
Please register this product on line at www.sony.com/ to lock the controls. If the signal is strong, you can scan for stations. Press
productregistration. Stop playback xSTOP
The hold function only locks the radio operation MENU repeatedly to set the cursor in the display to
<http://www.sony.com/productregistration> Wind rapidly* M or m buttons, MENU button, SET button, PRESET/ TUNE MODE and press SET to display “MANUAL”.
Proper registration will enable us to send you periodic TUNING +/– button and ENTER button. Then hold down PRESET/TUNING +/– for a few
mailings about new products, services, and other important seconds.
* If you leave the unit after the tape has been wound or
announcements. Registering your product will also allow rewound, the battery will be consumed rapidly. Be Emphasizing bass sound To turn off the radio
us to contact you in the unlikely event that the product sure to press xSTOP.
needs adjustment or modification. Thank you.
Press MENU repeatedly to set the cursor to MB Press RADIO OFF.
(mega bass) in the display. Then, press SET to turn
Note MB on. With each press, the indications change as
INFORMATION To improve broadcast reception C
• Do not open the cassette holder while the tape is follows.
This device complies with Part 15 of the FCC Rules. running. •For TV/WB/FM: Extend the headphones/
Operation is subject to the following two conditions: MB (mega bass) : emphasizes bass sound earphones cord (antenna). If the reception is still
(1) This device may not cause harmful interference, and No message: off (normal) not good, press MENU repeatedly to set the cursor
(2) this device must accept any interference received, Notes in the display to FM MODE. Then press SET to
including interference that may cause undesired operation. switch between “LOCAL” and none (DX) for best
• If the sound is distorted with the mode “MB”, turn
You are cautioned that any changes or modifications not down the volume or select normal mode. reception.
expressly approved in this manual could void your • Bass emphasis may not show great effect if the •For AM: Reorient the unit itself.
authority to operate this equipment. volume is turned up too high.
3 Press PRESET/TUNING +/–.
Specifications
Presetting Radio Stations To cancel a stored station • Frequency range Battery life* (approximate hours)
You can preset up to 40 stations (7 for TV, 4 for WB, 1 Follow the procedure above and in step 3, select TV: 2 - 13 ch WB (Weather): 1 - 7 ch Sony alkaline LR6 (SG)** Sony R6P (SR)
24 for FM and 5 for AM ). the station you want to cancel and then press FM: 87.5 - 108 MHz AM: 530 - 1 710 kHz
Tape playback 35 9
ENTER. The frequency digits will flash in the • Power requirements
Presetting Automatically Scanned display. 1.5V DC, battery size AA (R6) x 1 Radio reception 40 14
Stations 2 Press and hold PRESET/TUNING +/– until • Dimensions (w/h/d)
Approx. 83.6 x 112.0 x 28.3 mm (3 3⁄8 × 4 1⁄2 × 1 1⁄8 inches) * Measured value by the standard of JEITA (Japan Electronics
1 Press TV/WB or FM/AM. “- - - -” is displayed. Press ENTER while “- - - -” is excl. projecting parts and controls and Information Technology Industries Association). (Using
2 Press and hold ENTER for more than 3 flashing. A preset number will flash in the display. • Mass a Sony HF series cassette tape)
seconds. 3 Press PRESET/TUNING +/– repeatedly to select Approx. 138 g (4.9 oz) (main unit only) **When using a Sony LR6(SG) “STAMINA” alkaline dry
the preset number you want to cancel and press battery (produced in Japan).
Preset number 1 will flash in the display and • Supplied accessories
ENTER. Stereo headphones or Stereo earphones (1) Note
the Walkman starts scanning the stations Carrying case with belt clip(1) • The battery life may be shorter depending on the operating
from the lower frequencies and stops for Scanning the preset radio stations — condition, the surrounding temperature and battery type.
Design and specifications are subject to change without notice.
about 4 seconds when a station is received. DAPS (Digital Auto Preset Scanning)
3 If you wish to preset the currently received
1 Press TV/WB or FM/AM repeatedly to select On headphones/earphones
station, press ENTER while the preset number SONY WM-FX488
the desired band and to turn on the radio. Road safety
is flashing. Tested to Comply
2 Press and hold TV/WB or FM/AM pressed in Do not use headphones/earphones while driving,
The received station is preset on preset cycling, or operating any motorized vehicle. It may With FCC Standards
step 1 for 2 seconds or more.
number 1 and the unit starts scanning for the create a traffic hazard and is illegal in some areas. It FOR HOME OR OFFICE USE
next receivable station. The preset stations of the selected band will can also be potentially dangerous to play your
be played for about 5 seconds each. (During headphones/earphones at high volume while
4 Repeat Step 3 until all receivable stations are walking, especially at pedestrian crossings. This warranty is valid only in the United States.
DAPS the indicators in the display flash.) You should exercise extreme caution or discontinue
preset.
3 Press TV/WB or FM/AM again to select the use in potentially hazardous situations.
To stop scanning station while the desired preset station is Preventing hearing damage
Press RADIO OFF. The radio is turned off at the being played. Do not use headphones/earphones at high volume.
same time. Hearing experts advise against continuous, loud
Notes and extended play. If you experience a ringing in
Notes • If there are no stations stored, the DAPS function does your ears, reduce the volume or discontinue use.
• If stations are already stored, the newly preset not work.
stations replace the old ones when the above • Until a station is selected in step 3, the DAPS function Caring for others
procedure is completed. Keep the volume at a moderate level. This will
turned on in step 2 will continue. allow you to hear outside sounds and to be
• If stations cannot be preset automatically, preset them • In step 2 or 3, if you select a band which you did not considerate to the people around you.
manually. select in step 1 by pressing TV/WB or FM/AM, the
newly selected band will be played normally. On maintenance
Presetting Stations Manually • Clean the tape head and tape path using a cotton
swab and commercially available cleaning
1 Press TV/WB or FM/AM. solvent after every 10 hours of use.
2 Press ENTER. Precautions • To clean the exterior, use a soft cloth slightly
moistened in water. Do not use alcohol, benzine
The frequency digits will flash in the display. On batteries or thinner.
• Do not carry dry batteries with coins or other metallic objects. • Clean the headphones/earphones plugs
3 While the frequency digits are flashing, tune periodically.
It can generate heat if the positive and negative terminals of
in to a station you wish to store using the batteries are accidentally contacted by a metallic object.
PRESET/TUNING +/– and press ENTER. • When you are not going to use your Walkman for a long time, If you have any questions about this product, you
remove the battery to prevent damage from battery leakage may call:
The first available preset number will flash in and corrosion. Sony Direct Response Center 1-(800)-222-7669
the display. or write to: Sony Direct Response Center 12451
4 While the preset number is flashing, select the On handling Gateway Blvd. Fort Myers, FL 33913
• Do not leave the unit in a location near heat sources, or in a
preset number you want using PRESET/ place subject to direct sunlight, excessive dust or sand,
TUNING +/– and press ENTER. moisture, rain, mechanical shock, or in a car with its windows Declaration of Conformity
closed. Trade Name: SONY
Notes • We do not recommend the use of tape longer than 90 minutes. Model No.: WM-FX488
• If you cannot complete step 3 or 4 while the indicators They are very thin and tend to be stretched easily. This may Responsible Party: Sony Electronics Inc.
are flashing, repeat from step 2. cause malfunction of the unit or sound deterioration. Address: 680 Kinderkamack Road,
• The LCD display may become hard to see or slow down when Oradell, NJ 07649 USA
• If a station is already stored, the new station replaces using the unit at high temperatures (above 40°C/104°F) or at
the old one. Telephone No.: 201-930-6972
low temperatures (below 0°C/32°F). At room temperature, the
display will return to its normal operating condition. This device complies with Part 15 of the FCC
Playing the preset radio stations • If the unit has not been used for a long time, set it in the Rules. Operation is subject to the following two
playback mode to warm it up for a few minutes before you conditions: (1) This device may not cause
1 Press TV/WB or FM/AM. start using it again. harmful interference, and (2) this device must
2 Press MENU repeatedly to set the cursor in accept any interference received, including
the display to TUNE MODE. Then press SET interference that may cause undesired
to display “PRESET”. operation.

You might also like