Professional Documents
Culture Documents
May 2017
DT81-UP
UENR6867-01
42 Page,
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.
Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
T
the gauge of the temperature or pressure.
© 2017 Caterpillar CAT, CATERPILLAR, their respective logos, “Caterpillar Yellow”, and the POWER EDGE trade dress as well as
All Rights Reserved corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
J J
I I
335245
UENR6867-01
CONNECT C10 TO C8.
GY 16
GY 16
335245
335245
42 Page,
H H
335245
335245
335245
335245
16 16
G 17 17
G
18 18
31 31 IF MACHINE HAS PIPE RACK INTERLOCK
OPTION DISCONNECT C9 FROM C8. THEN
2 32 CONNECT C10 TO C8.
1 1
26 26
24 24
10 10
MUST CUT 24
VDC JUMPER
F F
E E
D D
01
C C
01
GY/1 18
B B
A 01 A
THIS SCHEMATIC IS FOR THE MD6290 ROTARY BLASTHOLE DRILL WITH CAT ENGINE C15/C27 (FOR MACHINES
MANUFACTURED JULY 2010 - PRESENT) ELECTRICAL SYSTEM
MEDIA NUMBER: UENR6867-01
SCHEMATIC PART NUMBER: 4570412, CHANGE: XX, VERSION: XX
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1