20
Press-fitting
Functional sequence
Press-fting clamp sleees Certain workpieces tend to deform easily during processing and clamping. In the
4 Baste workpiece
2 Preumaticeyinder
3 Clamp steve (workpiece
tebe ited)
44 Supperttable
5 Seldowm aren for faked
workplaces
4 Conveyor chan drive
7 Motor for conveyor
interests of accuracy and to prevent deformity, these must be fitted with a
temporary clamp sleeve to allow further processing. This is achieved by using
the system shown above, which is partially automated, The clamp sleeves are
first placed into a carrier by hand. The workpiece Is then moved into the clam-
ping position against the stop of the more powerful right-hand cylinder. This is
followed by longitudinal pressing. After thi, the stap cylinder retracts again,
allowing the feed cylinder in a second action to push the finished workpiece
conto the outward transfer conveyor belt. The clamp steeves must be removed
again after processing has been completed, The workpieces are moved by hand
from the conveyors to the side setdown area,
‘Suitable components:
Flat cylinder 02H...
Mounting accessories
Twin cylinder ADVUT..
Safety start block for two-handed operation
Pneumatic single pilot valve VL.
Proximity switch SM.
Fittings
Standard cylinder DNC....
Standard cylinder DNC-Q...
Foot mounting HNG...