Professional Documents
Culture Documents
本 零 件 图 册 适 用 于 我 公 司 生 产 的1.5T 内 燃 平 衡 重 式 叉 车 , 以 便 用 户 在 修 理
更换叉车零部件时,从中查找出所需的零件名称、结构及安装位置,并作为订货
参考。
在订货时,必须说明原叉车的型号及出厂日期,并根据本图册,说明零件的
详 细 名称、 标 号、数 量 及完整 的 代号。
我公司叉车根据用户和生产发展,将不断地进行改进,故图册内容可能在一
定 的 时期将 有 更新, 待 再版时 予 以修改 , 敬请用 户 注意 。
Introduction
This parts manual is applied for the 1.5T balanceweight type forklift produced by
our plant. It is convenient for users to identify the description, the structure and
the assembling location of the parts replaced or repaired, and to put order on
them.
When ordering parts, it is necessary to state the model and the date of
manufacture of the forklift, and according to the parts manual, give the
description, specification, quantity and code about the part you ordered.
Owing to users and our improvement of product, our products will be changed
continuously, the information contained in this book may be changed without
notice.
For improving our work, customers are sincerely requested to give us comments
and suggestions.
VER 1 , REV 2 .
Dec. 2015
1
查 询 方 法:
1.在 目 录 中 找 到 相 应 的 系 统 或 总 成;
2.翻 至 所 标 页 数,找 到 该 图;
3.在 其 图 中 找 出 所 需 零 部 件,以 及 它 所 标 注 的 序 号;
4.根 据 这 个 序 号,在 其 后 附 表 中 可 以 查 到 系 统 或 零 件 的 详 细 信 息.
Indexing Way:
1.Find out the system or assembly from the indexing.
2.Turn to above page, find out the drawing.
3. Find out the part you require and its item number from the
drawing.
4.According to the item number, find out detailed information about the
system or assembly from the attached table.
2
目录/Contents
发动机总成/Engine assembly ..................................................................................... 1
空滤器总成/Air cleaner assembly ............................................................................... 2
散热器总成/Radiator assembly .................................................................................. 3
散热器总成/Radiator assembly ................................................................................... 4
燃油装置总成/Fuel unit assembly ............................................................................... 6
消声器总成/Muffler assembly ....................................................................................... 8
传动系统/Drive system ............................................................................................... 9
变速箱(Ⅰ)/Gearbox(Ⅰ) ............................................................................................ 11
变速箱(Ⅱ)/Gearbox(Ⅱ) ............................................................................................ 13
变速箱(Ⅲ)/Gearbox(Ⅲ) ............................................................................................. 15
差速器总成/Differential assembly ................................................................................ 18
主轴组件/Main shaft assembly ................................................................................... 20
离合器/Clutch ............................................................................................................. 22
传动系统/Drive system ............................................................................................... 24
变速箱(Ⅰ)/Gearbox(Ⅰ) ............................................................................................ 25
变速箱(Ⅱ)/Gearbox(Ⅱ) ............................................................................................ 28
离合器总成/Clutch assembly ....................................................................................... 30
油泵/Oil pump ............................................................................................................. 32
控制阀总成/Control valve assembly ............................................................................ 33
微动阀/Inching valve assembly ................................................................................... 34
减速传动和差速器/Reduction gear & Differential ........................................................ 36
驱动桥总成/Drive axle assembly ................................................................................. 38
驱动桥/Drive axle ....................................................................................................... 39
转向操纵总成/Steering control assembly .................................................................... 41
转向桥总成/Steering axle assembly ............................................................................ 43
转向轮/Steer wheel .................................................................................................... 45
油门操纵系统/Throttle control system ......................................................................... 46
熄火操纵系统/Flameout control system ....................................................................... 48
行车制动系统/Service brake system ........................................................................... 49
3
目录/Contents
行车制动系统/Service brake system .............................................................................. 50
停车制动系统/Parking brake system ............................................................................. 51
车架/Chassis ............................................................................................................... 52
覆盖件系统/Outer panel system ..................................................................................... 54
门架(基本型)/Mast (normal mast) ............................................................................... 56
门架(二级全自由)/Mast(full free 2-stage mast) ............................................................. 59
门架(三级全自由)/Mast(full free 3-stage mast) ............................................................. 61
货叉及货叉架/Fork & Lift bracket(normal mast) ............................................................. 64
起升油缸(基本型)/Lift cylinder (normal mast) .............................................................. 66
前起升油缸/Front lift cylinder ........................................................................................ 69
后起升油缸(二级全自由)/Rear lift cylinder (full free 2-stage mast) ................................. 72
后起升油缸(三级全自由)/Rear lift cylinder (full free 3-stage mast) ................................. 75
倾斜油缸总成/Tilt cylinder assembly ............................................................................. 78
门架侧移管路(基本型)/Side shifting pipe mast(normal mast)
.............................................. 80
门架侧移管路(二级全自由)/Side shifting pipe mast(full free 2-stage mast) .................... 82
门架侧移管路(三级全自由)/Side shifting pipe mast(full free 3-stage mast) .................... 84
门架起升管路(二级全自由)/Lift pipe mast(full free 2-stage mast) ................................... 86
门架起升管路(三级全自由)/Lift pipe mast(full free 3-stage mast) ................................... 88
多路阀操纵/Multi-way valve control ................................................................................ 90
液压系统/Hydraulic system .......................................................................................... 92
液压油箱盖板总成/Hydraulic oil tank cover plate ............................................................ 95
护顶架/Overhead guard ............................................................................................... 96
电气系统/Electric system ............................................................................................. 98
标牌/Label ...................................................................................................................100
平衡重/Counter weight .............................................................
..
...................................102
4
发动机总成/Engine assembly
LG15D(T)
8
7
6
4
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51203103114 GB/T5782 螺栓M10X110 Bolt M10×110 2
2 30001106402 30D-0152001 垫圈 Washer 2
3 30001109003 30D-0152002 减震垫 Rubber gasket 2
4 30001106403 30D-0152003 垫圈 Washer 2
5 30001112306 30D-0152004 套管 Sleeve 2
6 30001109012 30D-0152005 减震垫 Rubber gasket 2
7 30002118201 LG0100DT.02.03-001 垫片 Gasket 2
8 51347000419 GB/T6184 螺母M10 Nut M10 2
9 30001012011 LG0015D.02.04 发动机总成 Engine assembly 1 NC485BPG-511
1
空滤器总成/Air cleaner assembly
LG15D(T)
7
9
2
7 8
3
1 2 3 4
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51204090914 GB/T5783 螺栓M8X16 Bolt M8×16 2
2 51421090115 GB/T97.1 垫圈8 Washer 8 4
3 51401090107 GB/T93 垫圈8 Washer 8 4
4 51307000919 GB/T6170 螺母M8 Nut M8 2
5 30001110000 LG0015D.01.01-001 空滤支架 Bracket 1
6 30001014809 LG0030D.01.01.01 空滤器总成 Air cleaner assembly 1
7 56171002201 JB/T8870 喉箍d80(60~80) Hoop d80(60~80) 4
8 30001106095 LG0015D.01.01-004 成型管 Molding pipe 1
9 30001106064 LG0015D.01.01-003 成型管 Molding pipe 1
2
散热器总成/Radiator assembly
LG15D
6
7
9 5
5
7
8
13 12
12 10
11
1 2
12 3
12 5
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 4
2 51401090107 GB/T93 垫圈8 Washer 8 4
3 51421090115 GB/T97.1 垫圈8 Washer 8 4
4 30001016307 LG0015D.01.02.01 散热器总成 Radiator assembly 1
5 30001109004 LG0030D.01.02-003 减震垫 Rubber gasket 6
6 51204101614 GB/T5783 螺栓M10X50 Bolt M10×50 2
7 51420100121 GB/T96.1 垫圈10 Washer 10 4
8 51341000619 GB/T889.1 螺母M10 Nut M10 2
9 30001115002 LG0030D.01.02-005 支架 Bracket 1
10 30001115001 LG0030D.01.02-004 支架 Bracket 1
11 30001106065 LG0015D.01.02-001 成型管 Molding pipe 1
12 56171000601 JB/T8870 喉箍d50(32~50) Clip d50(32~50) 4
13 30001106066 LG0015D.01.02-002 成型管 Molding pipe 1
3
散热器总成/Radiator assembly
LG15DT
13
14
12
16
12
14
15
11
20 19
5
19
17
6
7 4
1 2
3
9 10 8 12
19
19
18
4
散热器总成/Radiator assembly
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 4
2 51401090107 GB/T93 垫圈8 Washer 8 4
3 51421090115 GB/T97.1 垫圈8 Washer 8 4
4 30001107800 LG0030DT.01.01-001 管夹 Clip 2
5 30001109234 LG0030DT.01.01-002 胶管 Hose 1
6 30001109235 LG0030DT.01.01-003 胶管 Hose 1
7 56171002301 JB/T8870 喉箍d25(16~25) Hoop d25(16~25) 4
8 30001109400 LG0030DT.01.01-004 铰接螺栓 Hinged bolt 2
9 30001109500 LG0030DT.01.01-005 铰接体 Hinged unit 2
10 56147010301 JB/T982 组合垫圈14 Combination asher14 4
11 30001016371 LG0015DT.01.01.01 散热器总成 Radiator assembly 1
12 30001109004 LG0030D.01.02-003 减震垫 Rubber gasket 6
13 51204101614 GB/T5783 螺栓M10X50 Bolt M10×50 2
14 51420100121 GB/T96.1 垫圈10 Washer 10 4
15 51341000619 GB/T889.1 螺母M10 Nut M10 2
16 30001115001 LG0030D.01.02-004 支架 Bracket 1
17 30001115002 LG0030D.01.02-005 支架 Bracket 1
18 30001106065 LG0015D.01.02-001 成型管 Molding pipe 1
19 56171000601 JB/T8870 喉箍d50(32~50) Hoop d50(32~50) 4
20 30001106066 LG0015D.01.02-002 成型管 Molding pipe 1
5
燃油装置总成/Fuel device assembly
LG15D(T)
10
1 3 11
5
7
8
2
4 9
12
13
6
燃油装置总成/Fuel device assembly
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30001109202 30D-0131004 胶管 Hose 1
2 30001109203 30D-0131003 胶管 hose 1
3 56171000101 JB/T8870 喉箍d16(10~16) Hoop d16(10~16) 4
4 30001015915 LG0015D.01.03.02 燃油箱盖板 Fuel tank cover plate 1
5 30001112800 LG0030D.01.03.02 通气帽 Air-vent cap 1
6 30001111512 LG0015D.01.03-001 密封垫 Seal gasket 1
7 51158170404 GB/T818 螺钉M5X12 Screw M5×12 5
8 51421070115 GB/T97.1 垫圈5 Washer 5 5
9 51401070107 GB/T93 垫圈5 Washer 5 5
10 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 8
11 60980000546 30D-0131006 垫圈8 Washer 8 8
12 30001015100 LG0030D.01.03.03 滤芯总成 Filter element assembly 1
13 60980000538 20B-1206005 磁铁50X25X8 Magnet 50×25×8 1
7
消声器总成/Muffler assembly
LG15D(T)
5 4 3 2 7
9
6
10
8
8
10
11
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30001015401 LG0015D.01.04.01 排气管总成 Vent-pipe assembly 1
2 51307000919 GB/T6170 螺母M8 Nut M8 2
3 51401090107 GB/T93 垫圈8 Washer 8 2
4 51421090115 GB/T97.1 垫圈8 Washer 8 2
5 30001105101 LG0030D.01.04.02-001 U型卡环套 U-clamp sheath 1
6 30001105001 LG0030D.01.04.02-002 U形螺栓 U-bolt 1
7 30001016804 LG0015D.01.04.02 消声器总成 Muffler assembly 1
8 30001113900 30D-0141001 橡胶垫 Rubber shim 4
9 60911011061 30D-0141004 六角螺栓 Bolt 2
10 51420100121 GB/T96.1 垫圈10 Washer 10 4
11 51341000619 GB/T889.1 螺母M8 Nut M8 2
8
传动系统/Drive system
LG15D
14
15
13
12
9
6 7
8
7
11
10
3 4
3
4
9
传动系统/Drive system
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51513121202 GB/T119.1 销8X20 Pin8×20 1
2 30002111503 LG0015D.02-001 密封垫 Seal gasket 1
3 51204101314 GB/T5783 螺栓M10X35 Bolt M10×35 19
4 51401100107 GB/T93 垫圈10 Washer 10 19
5 60200000372 LG0015D.02.03.02 变速箱总成 Transmission assembly 1 JDS18Ⅱ
6 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 6
7 51401090107 GB/T93 垫圈8 Washer 8 8
8 51204091414 GB/T5783 螺栓M8X40 Bolt M8×40 2
9 30002107800 LG0030D.02-002 管夹 Clip 2
10 51307000919 GB/T6170 螺母M8 Nut M8 2
11 51421090115 GB/T97.1 垫圈8 Washer 8 2
12 30002116603 LG0015D.02.03-003 换向杆 Reversing lever 1
13 30002118006 LG0015D.02.03-004 变速杆 Gear shifter 1
14 30002132000 LG0030D.02.02-003 手柄 Knob 1
15 30002132001 LG0030D.02.02-004 手柄 Knob 1
10
变速箱(Ⅰ)/Gearbox(Ⅰ)
LG15D
11
变速箱(Ⅰ)/Gearbox(Ⅰ)
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 JDS25-0101 壳体 Housing 1
2 YQX25-0101 轴承座 Bearing seat 2
3 YQX25-0004 锁片 Lock plate 4
4 YQX30-0101 螺栓 Bolt 4
5 YQX25-2000 差速器总成 Differential assembly 1
6 YQX25-0002 齿轴 Gear shaft 1
7 YQX30-0019 衬套 Bushing 1
8 YQX18-0002 螺旋伞齿轮 Spiral bevel gear 1
9 GB297-94 轴承32207 Bearing 32207 2
10 YQX30-0017 垫片 Gasket 按需
11 GB1235-76 O形密封圈75X3.1 O-ring 75×3.1 2
12
变速箱(Ⅱ)/Gearbox(Ⅱ)
LG15D
13
变速箱(Ⅱ)/Gearbox(Ⅱ)
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 JB/ZQ4447-86 螺塞R1/2 Plug R1/2 1
2 JDS30-0042 挡板 Baffle 1
3 GB93-87 弹簧垫圈10 Spring washer 10 12
4 GB5783-86 螺栓M10X20 Bolt M10×20 12
5 GB1235-76 O形密封圈28X3.5 O-ring 28×3.5 1
6 JDS30-0017 外齿弹性垫圈 Spring washer 1
7 JDS30-0010 滑动螺杆 Sliding screw stud 1
8 JDS30-0001 塞体 Plug 1
9 JDS30-0002 盖 Cover 1
10 Q/301B202-8 密封圈14X24X1 Seal ring 14×24×1 1
11 JK611T 倒车灯开关 Backup lamp switch 1
12 JDS30-0003 拨叉 Shift fork 2
13 JDS30-0004 弹簧 Spring 2
14 GB308-89 钢球10.0000 G2006 Steel ball 2
15 JDS30-0006 传动杆 Drive rod 2
16 GB1099-79 半圆键5X19 woodruff Key5×19 2
17 GB1235-76 O形密封圈22X2.4 O-ring 22×2.4 2
18 GB894.1-86 轴用弹性挡圈22 Snap ring 22 2
19 JDS30-0005 换挡杆 Shifting rod 1
20 GB1235-76 O形密封圈20X2.5 O-ring 20×2.5 1
21 JDS30-0043 塞 Plug 1
22 GB1235-76 O形密封圈35X3.1 O-ring 35×3.1 1
23 JDS30-0041 轴臂 Shaft arm 1
24 GB6170-86 螺母M10 Nut M10 1
25 GB5783-86 螺栓M10X45 Bolt M10×45 1
26 GB93-87 弹簧垫圈8 Spring washer 8 2
27 GB5783-86 螺栓M8X20 Bolt M8×20 2
28 JDS30-0008 箱盖垫片 Gasket 1
29 JDS30-0007 箱盖 Case cover 1
14
变速箱(Ⅲ)/Gearbox(Ⅲ)
LG15D
15
变速箱(Ⅲ)/Gearbox(Ⅲ)
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 GB893.2-86 孔用弹性挡圈80 Spring sprag 80 1
2 JDS30-0009 轴承垫圈 Bearing washer 1
3 GB894.1-86 轴用弹性挡圈35 Spring sprag 35 1
4 JDS30-0202 隔圈 Spacer 1
5 GB305-89 止动环72/78.6 Stop ring 72/78.6 1
6 GB276-94 轴承6207N Bearing 6207N 1
7 JDS30-0203 隔套 Spacer 1
8 GB276-94 轴承6207 Bearing 6207 1
9 JDS30-0201 输入齿轮 Input gear 1
10 JDS30-0301 主动轴 Drive shaft 1
11 GB894.1-86 轴用弹性挡圈25 Snap ring 25 2
12 GB276-94 轴承6005 Bearing 6005 1
13 GB893.2-86 孔用弹性挡圈47 Spring sprag 47 1
14 JDS30-0019 油封25X40X8 Oil seal 25×40×8 1
15 JDS30-0016 轴承架 Bearing stand 1
16 GB1235-76 O形密封圈42X3.5 O-ring 42×3.5 1
17 JDS30-0018 轴环 Shaft collar 1
18 JDS30-0400 主轴组件 Main Shaft 1
19 JDS30-0029 轴承保持圈 Bearing holding ring 1
20 GB276-94 轴承6306 Bearing 6306 1
21 JDS30-0027 隔圈 Spacer 1
22 GB894.1-86 轴用弹性挡圈30 Spring sprag 30 1
23 GB893.2-86 孔用弹性挡圈72 Spring sprag 72 1
24 JDS18-0001 输出轴 Output shaft 1
25 GB297-94 轴承32208 Bearing 32208 1
26 JDS30-0011 调整垫 Adjusting gasket 按需
27 JDS30-0012 止推垫圈 Thrust washer 1
30 JDS30-0013 衬套 Bushing 1
31 JDS30-0015 衬套 Bushing 1
34 JDS30-0022 隔环 Spacer 1
16
变速箱(Ⅲ)/Gearbox(Ⅲ)
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
37 25×33×24 滚针轴承 Needle bearing 2
38 JDS30-0035 惰轮 Idler wheel 1
39 JDS30-0036 衬套 Spacer 1
40 JDS30-0034 惰轮轴 Idler wheel shaft 1
41 GB308-89 钢球6.3500 G2006 Steel ball 1
17
差速器总成/Differential assembly
LG15D
18
差速器总成/Differential assembly
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 YQX25-2003 大齿圈 Ring gear 1
2 YQX25-2101 差速器右半壳 Right half case of differential 1
3 YQX25-2102 差速器左半壳 left half case of differential 1
4 YQX25-2002 螺栓 Bolt 16
5 YQX25-2001 锁片(A) Locking split 8
6 GB6176-86 螺母M10X1.25 Nut M10×1.25 28
7 YQX25-2007 垫圈 Washer 2
8 YQX25-2009 半轴齿轮 Axle shaft gear 2
9 YQX25-2008 齿轮轴(Ⅰ) Gear shaft 1
10 YQX25-2005 齿轮轴(Ⅱ) Gear shaft 1
11 GB119-86 圆柱销B6X30 Cylindrical pin B6×30 1
12 YQX25-2006 行星齿轮 Planetary gear 4
13 YQX25-2004 止推垫圈 Thrust washer 4
14 GB276-94 轴承6213 Bearing 6213 2
15 YQX30-2104 螺栓 Bolt 12
16 YQX30-2103 锁片(B) Locking split 6
19
主轴组件/Main shaft assembly
LG15D
20
主轴组件/Main shaft assembly
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 JDS30-0039 主轴 Main shaft 1
2 56×61×30 滚针轴承 Needle bearing 2
3 JDS30-0037 低速齿轮 Low speed gear 1
4 JDS30-0030 同步环 Synchronic ring 4
5 JDS30-0031 弹簧 Spring 4
6 JDS30-0028 离合器从动盘毂 Clutch hub plate 2
7 JDS30-0032 嵌块 Block 6
8 JDS30-0033 1/2 档啮合套 Gear sleeve 1
9 GB894.1-86 轴用弹性挡圈48 Snap ring 48 2
10 35×40×27 滚针轴承 Needle bearing 2
11 JDS30-0038 高速齿轮 High speed gear 1
12 JDS30-0026 止推垫圈 Thrust washer 2
13 GB283-94 轴承NJ306 Bearing NJ306 1
14 JDS30-0027 隔圈 Spacer 1
15 GB894.1-86 轴用弹性挡圈30 Spring sprag 30 1
16 JDS30-0024 倒档齿轮 Reverse gear 1
17 JDS30-0044 啮合套 meshing sleeve 1
18 JDS30-0025 前进档齿轮 Forward gear 1
21
离合器/Clutch
LG15D
22
离合器/Clutch
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 JDS30Ⅱ-0001 纸垫 Paper gasket 1
2 JDS30Ⅱ-0002 离合器壳 Clutch housing 1
3 JDS30Ⅱ-0005 缓冲垫 Damping cushion 1
4 JDS30Ⅱ-0004 离合器壳盖 Clutch housing cover 1
5 JDS30Ⅱ-0003 分离叉保护罩 Cover dust 1
6 GB93-87 垫圈8 Washer 8 2
7 GB97.1-85 平垫圈8 Plain washer 8 2
8 GB5783-86 螺栓M8X16 Bolt M8×16 2
9 GB6170-86 螺母M8 Nut M8 2
GB93-87
10 垫圈6 Washer 6 4
GB97.1-85
11 平垫圈6 Plain washer 6 4
GB5783-86
12 螺栓M6X12 Bolt M6×12 4
GB93-87
13 垫圈10 Washer 10 7
GB5783-86
14 螺栓M10X30 Bolt M10×30 7
JDS30Ⅱ-0006
15 分离轴承套筒 Release bearing sleeve 1
JDS30Ⅱ-0007
16 分离轴承 Release bearing 1
JDS30Ⅱ-1000
17 压盘及盖总成 Pressure plate and cover assembly 1
JDS30Ⅱ-2000
18 离合器摩擦片总成 Clutch friction disc assembly 1
JDS30Ⅱ-0011
19 调整螺母 Adjusting nut 1
JDS30Ⅱ-0010
20 支撑螺栓 Bearing bolt 1
JDS30Ⅱ-0009
21 弹性挡圈 Spring sprag 1
JDS30Ⅱ-0008
22 分离叉 Disengaging fork 1
23
传动系统/Drive system
LG15DT
7
6
5 4
6
7
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30002111503 LG0015D.02-001 密封垫 Seal gasket 1
2 51513121202 GB/T119.1 销8X20 Pin8×20 1
3 30002020347 LG0015DT.02.03 变速箱总成 Transmission assembly 1 YQXD18A
24
变速箱(Ⅰ) /Gearbox(Ⅰ)
LG15DT
25
变速箱(Ⅰ) /Gearbox(Ⅰ)
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 Y30H-01010 轴承座螺栓 Bolt of bearing seat 4
2 YQX25-01008 轴承座锁片 Locking plate 4
3 YQX25-01002 轴承座 Bearing seat 2
4 YQX25-01001 液力箱体 Hydraulic case 1
5 Y30H-01006A 加油管 Oil filler pipe 1
6 Y30H-01007B 加油口盖 Oil filler pipe 1
7 GB1235-76 O形圈15X2.4 O-ring 15×2.4 2
8 YQX18-02000 离合器总成 Clutch assembly 1
9 GB/T276 深沟球轴承6206 Ball bearing 1
10 Y30H-04001 惰轮轴 Idler wheel shaft 1
11 Y30H-04002 惰轮 Idler wheel 1
12 GB893.1-86 弹性挡圈24 Spring sprag 24 2
13 GB/T276 深沟球轴承6207 Ball bearing 2
14 Y30H-03002 输出齿轮 Output gear 1
15 GB1235-76 O形圈24X2.4 O-ring 24×2.4 1
16 GB1235-76 O形圈28X2.4 O-ring 28×2.4 1
17 GB/T70.1 螺钉M10X25 Screw M10×25 1
18 GB/T70.1 螺钉M10X30 Screw M10×30 4
19 Y30H-03009 防松螺母 Lock nut 1
20 Y30H-03006A 液力输出轴垫片 Hydraulic output shaft gasket AR Φ0.5mm
Y30H-03006B 液力输出轴垫片 Hydraulic output shaft gasket AR Φ0.2mm
Y30H-03006C 液力输出轴垫片 Hydraulic output shaft gasket AR Φ0.1mm
Y30H-03006D 液力输出轴垫片 Hydraulic output shaft gasket AR Φ0.15mm
21 GB/T297 圆锥滚子轴承30208 Tapered roller bearing 1
22 GB1235-76 O形圈80X3.1 O-ring 80×3.1 1
23 Y30H-03003 油封保持架 oil seal cage 1
24 Y30H-03007 油封 Oil seal 1
25 GB/T297 圆锥滚子轴承32208 Tapered roller bearing 1
26 Y30H-03008 轴环 Shaft collar 1
27 YQX18-03001 输出轴 Output shaft 1
28 Y30H-03005A 支承片垫片 Bearing plate spring AR Φ0.5mm
Y30H-03005B 支承片垫片 Bearing plate spring AR Φ0.2mm
Y30H-03005C 支承片垫片 Bearing plate spring AR Φ0.1mm
29 Y30H-03004 支承片 Bearing plate 1
30 GB93-87 弹簧垫圈8 Spring washer 4
31 GB5783-86 螺栓M8X20 Bolt M8×20 4
26
变速箱(Ⅰ) /Gearbox(Ⅰ)
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
32 Y30H-01004A 变矩器壳衬垫 Gasket 1
33 GB119-76 圆柱销A12X20 Cylindrical pin 2
34 JB/ZQ4446-86 螺塞Rc1/2″ Plug 5
35 JB/ZQ4446-86 螺塞Rc1/4″ Plug 3
36 Y30H-01003 变矩器壳 Torque converter housing 1
37 GB93-87 弹簧垫圈10 Spring washer 15
38 GB5782-86 螺栓M10X75 Bolt M10×75 1
39 GB5783-86 螺栓M10X30 Bolt M10×30 4
40 GB5782-86 螺栓M10X50 Bolt M10×50 1
41 GB5782-86 螺栓M10X55 Bolt M10×55 3
42 Y30H-05002 供油泵衬垫 Gasket 1
43 Y30H-05000 供油泵总成 Oil pump assembly 1
44 Y30H-07007 螺栓衬垫 Bolt gasket 6
45 GB5783-86 螺栓M8X35 Bolt M8×35 2
46 GB5783-86 螺栓M8X45 Bolt M8×45 4
47 Y30H-06100 变矩器组件 Torque converter element 1
48 Y30H-06200 输入板组件 Input plate element 1
49 Y30H-01013 粗滤器衬垫 Strainer gasket 1
50 Y30H-01102A 滤网组件 Screen element 1
51 Y30H-01101A 外置粗滤器壳 Strainer housing 1
52 JB982-77 组合密封垫16 Combination seal gasket 1
53 Y30H-01011 放油螺塞 Oil drain plug 1
54 Y30H-01016 飞轮壳 Flywheel housing 1
55 GB/T119.1 圆柱销10X24 Cylindrical pin 2
27
变速箱(Ⅱ) /Gearbox(Ⅱ)
LG15DT
28
变速箱(Ⅱ) /Gearbox(Ⅱ)
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 JB/ZQ4446-86 螺塞Rc1/8″ Plug 6
2 JB/ZQ4446-86 螺塞Rc1/4″ Plug 4
3 Y30H-D07001 壳体盖 Case cover 1
4 Y30H-07002 管接头 Pipe connector 1
5 GB93-87 弹簧垫圈10 Spring washer 8
6 GB5783-86 螺栓M10X55 Bolt M10×55 3
7 GB5783-86 螺栓M10X40 Bolt M10×40 5
8 Y30H-07010 滤油器(Ⅱ) Oil filter 1
9 Y30H-D07300 电磁阀 Solenoid valve 1
10 Y30H-07011 安全阀盖 Safety valve cap 1
11 Y30H-07012 安全阀衬垫 Safety valve gasket 1
12 Y30H-07013 弹簧 Spring 1
13 Y30H-07014 活塞 Piston 1
14 Y30H-07015 壳体盖衬垫 Gasket 1
15 Y30H-D07016 控制阀衬垫 Gasket 1
16 Y30H-D07100 电液控制阀 Electrohydraulic control valve 1
17 GB93-87 弹簧垫圈8 Spring washer 13
18 GB5783-86 螺栓M8X55 Bolt M8×55 3
19 GB5783-86 螺栓M8X50 Bolt M8×50 5
20 GB5783-86 螺栓M8X35 Bolt M8×35 2
21 GB1235-76 O形圈9X1.9 O-ring 9×1.9 2
22 Y30H-08010 微动阀衬垫 Inching valve gasket 1
23 Y30H-08000 微动阀总成 Inching valve assembly 1
24 GB5783-86 螺栓M8X25 Bolt M8×25 3
25 Y30H-01005A 变矩器壳盖 Torque converter case cover 1
26 GB818-85 螺钉M8X10 Screw M8×10 2
29
离合器总成/Clutch assembly
LG15DT
30
离合器总成/Clutch assembly
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
A YQX18-02000 离合器总成 Clutch assembly 1
1 Y30H-02100-1 输入轴总成 Input shaft assembly 1
2 Y30H-02002 倒车档齿轮 Reverse gear 1
3 Y30H-02001 前进档齿轮 Forward gear 1
4 YQX18-02012 端板 End plate 2
5 Y30H-02003 回程弹簧 Return spring 2
6 Y30H-02004 弹簧座 Spring seat 2
7 Y30H-02005 止推环A Thrust ring A 2
8 Y30H-02006 止推环B Thrust ring B 2
9 Y30H-02201 活塞 Piston 2
10 Y30H-02202 塞 Plug 2
11 GB308-89 钢球1/8″ Steel ball 2
12 Y30H-02008 隔片 Distance piece 6
13 Y30H-02007 摩擦片 Friction plate 6
14 Y30H-02009 密封环A Seal ring A 4
15 Y30H-02010 密封环B Seal ring 2
16 GB1235-76 O形圈40X3.5 O-ring 40×3.5 2
17 Y30H-02011A 卡环 Snap ring 2
18 GB/T276 深沟球轴承6206 Deep groove ball bearing 2
19 JB/T7918-97 滚针轴承K35X42X20 Needle bearing 2
20 GB894.1-86 弹性挡圈40 Snap ring 40 2
21 GB78-85 螺钉M8X8 Screw M8×8 2
22 YQX18-02013 碟形弹簧 Disk spring 2
31
油泵/Oil pump
LG15DT
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
A Y30H-05000 供油泵总成 Oil pump assembly 1
1 Y30H-05101 泵体 Pump body 1
2 Y30H-05102 衬套 Bushing 1
3 Y30H-07007 螺栓衬垫 Bolt gasket 2
4 Y30H-05004 油封 Oil Seal 1
5 GB/T3452.1 O形密封圈145X3.55 O-ring 1
6 Y30H-05001 锭子 Spindle 1
7 GB119-86 圆柱销B6X16 Cylindrical pin 2
8 Y30H-05201 主动齿轮 Drive gear 1
9 Y30H-05202 衬套 Bushing 1
10 Y30H-05003 被动齿轮 Driven gear 1
11 GB5783-86 螺栓M8×X25 Bolt M8×25 1
12 GB5783-86 螺栓M8X35 Bolt M8×35 1
32
控制阀总成/Control valve assembly
LG15DT
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
A Y30H-D07000 电液控制阀总成 Electrohydraulic control valve assembly 1
B Y30H-D07100 电液控制阀 Electrohydraulic control valve 1
1 Y30H-D07101 阀体 Valve body 1
2 Y30H-07109 阀芯 Valve plug 2
3 Y30H-07111 弹簧 Spring 2
4 Y30H-07110 弹簧 Spring 2
5 Y30H-07112 塞 Plug 2
6 Y30H-07108 塞 Plug 1
7 Y30H-07106 弹簧 Spring 1
8 Y30H-07107 弹簧 Spring 1
9 Y30H-07105 活塞 Piston 1
10 GB879-86 弹性圆柱销4X35 Elastic cylindrical pin 1
11 GB879-86 弹性圆柱销4X40 Elastic cylindrical pin 2
33
微动阀总成/Inching valve assembly
LG15DT
34
微动阀总成/Inching valve assembly
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
A Y30H-08000 微动阀总成 Inching valve assembly 1
1 GB893.1-86 挡圈30 Snap ring 1
2 Y30H-08001 阀体 Valve body 1
3 Y30H-08002 阀杆 Valve stem 1
4 Y30H-08003 滑阀 Slide valve 1
5 GB1235-76 O形圈28X2.65 O-ring 28×2.65 1
6 Y30H-08004 油堵 Oil stopper 1
7 GB893.1-86 挡圈28 Snap ring 1
8 Y30H-08006 微动弹簧(Ⅱ) Inching spring 1
9 Y30H-08005 微动弹簧(Ⅰ) Inching spring 1
10 Y30H-08007 堵块 Plug 1
11 Y30H-08008 油封30X16X7 Oil seal 1
12 Y30H-08009 油塞 Oil plug 1
13 JB/ZQ4446-86 螺塞Rc1/8″ Plug 2
35
减速传动和差速器/Reduction gear & Differential
LG15DT
36
减速传动和差速器/Reduction gear & Differential
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 YQX25-10001 左差速器壳 Left differential casing 1
2 GB5783-86 螺栓M10X25 Bolt M10×25 8
3 GB93-87 弹簧垫圈10 Spring washer 8
4 Y30H-09001 轴承盖 Bearing cover 2
5 YQX25-10007 半轴齿轮 Axle shaft gear 2
6 Y30H-09004 齿轴衬套 Gear shaft bushing 1
7 YQX25-10006A 半轴垫圈 Axle shaft washer 2 Φ1.8mm
YQX25-10006B 半轴垫圈 Axle shaft washer 2 Φ2.0mm
YQX25-10006C 半轴垫圈 Axle shaft washer 2 Φ2.2mm
YQX25-10006D 半轴垫圈 Axle shaft washer 2 Φ2.4mm
8 YQX25-10003 十字轴 Spider 1
9 YQX25-10005 行星齿轮 Planetary gear 4
10 YQX25-10002 右差速器壳 Right differential case 1
11 YQX25-10010 齿圈 Ring gear 1
12 Y30H-10008A 差壳螺栓 Bolt 12
13 YQX25-10009 齿圈锁片 Locking plate 6
14 YQX25-10008A 齿圈螺栓 Bolt 12
15 Y30H-10009 差壳锁片 Locking plate 6
16 YQX25-10004 行星垫圈 Planetary washer 4
17 GB6171-86 螺母M10X1.25 Nut M10×1.25 12
18 GB1235-76 O形圈75X3.1 O-ring 75×3.1 2
19 Y30H-09002A 齿轴垫片 Gear shaft gasket AR Φ0.5mm
Y30H-09002B 齿轴垫片 Gear shaft gasket AR Φ0.2mm
Y30H-09002C 齿轴垫片 Gear shaft gasket AR Φ0.1mm
Y30H-09002D 齿轴垫片 Gear shaft gasket AR Φ0.15mm
20 GBT297 圆锥滚子轴承32207 Tapered roller bearing 2
21 YQX18-09005 螺旋伞齿轮 Spiral bevel gear 1
22 GB/T276 深沟球轴承6211 Bearing,ball 2
23 YQX25-09003 齿轴 Gear shaft 1
37
驱动桥总成/Drive axle assembly
LG15D(T)
2
1
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 60205000169 LG0015D.02.01.01 轮胎总成6.5-10-10PR Tire 6.5-10-10PR 2
2 60205000170 LG0015D.02.01.02 轮辋焊合5.00F-10 Rim Weldment 5.00F-10 2
3 30002024505 LG0015D.02.02 驱动桥总成 Drive axle assembly 1
38
驱动桥/Drive axle
LG15D(T)
1
3
2
4
6
7
8
25
11 10
12
13
15 14
16
17
18
19
20
19
21
22
23
24
39
驱动桥/Drive axle
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
01 21233-7030 右边制动器 Right brake 1
02 CPC1.5-09 驱动桥壳 Axle housing, 1
03 Q901 通气塞(Z1/8") Air-vent plug 1 Q151B1435
04 CPC1.5-11 通气塞底座 Base of air-vent plug 1
05 21233-7030 左边制动器 Left brake 1
06 GB93-87 14 弹簧垫圈14 Spring washer 14 12
07 CPC1.5-02 制动器螺栓 Bolt 12
08 CPC1.5-08 衬套67X100X14 Bushing 67×100×14 2
09 CPC1.5-03A 轮毂螺栓 Hub bolt 12
10 CPC1.5-01 制动鼓 Brake drum 2
11 GB9877.1-88 油封100X125X12 Oil seal 100×125×12 2
12 GB297-84 轴承30213 Bearing 30213 2
13 CPC1.5-05 轮毂 Hub plate 2
14 CPC1.5-04A 轮毂螺母 Hub plate nut 12 Q30614
15 GB297-84 轴承32012 Bearing 32012 2
16 GB3452.1-82 0型密封圈67X2.65 O-ring 67×2.65 2
17 CPC1.5-07 环 Ring 2
18 GB9877.1-88 油封75X100X10 Oil seal 75×100×10 2
19 GB810-88 圆螺母M60X2 Round nut M60×2 4
20 GB/T858-88 垫圈60 Washer 2
21 半轴纸垫 Axle shaft paper gasket 2
22 CPC1.5-06 半轴 Axle shaft 2
23 GB/T95-85 垫圈 12 Washer 12 16
24 GB/T5785-86 螺栓M12X1.25X35 Bolt M12×1.25×35 16 10.9级
25 CPC1.5-10 螺塞 Plug 2
40
转向操纵总成/Steering control assembly
LG15D(T)
10
18
16
21
22 17 11
12
20
23
24
25
26
13 4
19 5
9 7
14 6 15 8 6
多路阀 3 2
1
Multi-way valve
41
转向操纵总成/Steering control assembly
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51207115114 GB/T5786 螺栓M12X1.25X25 Bolt M12×1.25×25 2
2 51401110107 GB/T93 垫圈12 Washer 12 2
3 51421110115 GB/T97.1 垫圈12 Washer 12 2
4 51204101514 GB/T5783 螺栓M10X45 Bolt M10×45 4
5 51401100107 GB/T93 垫圈10 Washer 10 4
6 51421100115 GB/T97.1 垫圈10 Washer 10 8
7 51420100121 GB/T96.1 垫圈10 Washer 10 4
8 51307001019 GB/T6170 螺母M10 Nut M10 4
9 51204101414 GB/T5783 螺栓M10X40 Bolt M10×40 4
10 60305000017 LG0030D.03.01.02 方向盘总成 Steering wheel assembly 1
11 51430080114 GB/T5287 垫圈6 Washer 6 4
12 51204081214 GB/T5783 螺栓M6X30 Bolt M6×30 4
13 30003033605 LG0030D.03.01.01 转向法兰总成 Flange assembly 1
14 30003132904 LG0030D.03.01-002 橡胶圈 Rubber ring 4
15 30003112301 LG0030D.03.01-003 套管 Sleeve 4
16 30003132905 LG0030D.03.01-004 橡胶圈 Rubber ring 4
17 30003112302 LG0030D.03.01-005 套管 Sleeve 4
18 30003033700 LG0030D.03.01.03-001 转向管柱总成 Steering column assembly 1
19 30003032207 LG0030D.03.01.04-001 锁紧手柄总成 Locking handle assembly 1
20 30003018110 LG0030D.03.01.05 支架焊合 Bracket weldment 1
21 30003111110 LG0030D.03.01-006 螺栓 Bolt 2
22 30003122305 LG0030D.03.01-007 衬套 Bushing 2
23 30003111108 LG0030D.03.01.04-002 螺栓 Bolt 1
24 30003135104 LG0030D.03.01.04-003 轴套 Sleeve 1
25 30003130901 LG0030D.03.01.04-004 螺母 Nut 1
26 30003111109 LG0030D.03.01.04-005 螺栓 Bolt 1
42
转向桥总成/Steering axle assembly
LG15D(T)
26
25
9
5 8
36 15
37
14
18
28
16 3
30 32
29
31
11 6 2
10 17
35
19 23 13
20
24
34 12
21
22
27
33
43
转向桥总成/Steering axle assembly
序号 代号 零部件名称 数量 备 注
Item
No Specification Description Q'ty Remark
1 WHZ1.5-001 转向桥体 Axle body 1
2 WHZ1.5-002 转向节调整垫 Steering knuckle adjusting gasket 5
3 WHZ1.5-003 右转向节 Right steering knuckle assembly 1
4 WHZ1.5-004 转向油缸总成 Steering cylinder assembly 1
5 WHZ1.5-005 连杆 Linkage 2
6 GB/T41-2000 螺母12 Nut M12 2
7 WHZ1.5-006 关节轴承GE15ES Joint bearing GEE15ES 4
8 WHZ1.5-007 连杆销 Linkage pin 4
9 WHZ1.5-008 紧固卡片 Fastening card 2
10 WHZ1.5-009 转向节主销 Main pin of steering knuckle 2
11 WHZ1.5-010 轮毂螺母 Hub bolt 12
12 GB290-82 滚针轴承942/25 Bearing 942/25 4
13 WHZ1.5-011 O型圈 O-ring 2
14 198905 单向推力球轴承 Bearing 2
15 WHZ1.5-012 骨架防尘圈 Frame dust ring 4
16 GB/T41-2000 螺母M12 Nut M12 2
17 WHZ1.5-013 六角紧定螺钉 Hexagon set screw 2
18 JB/T7940.1 直通式压注油杯 Straight press oil cup 2
19 WHZ1.5-014 骨架密封圈 Frame seal ring 2
20 GB/T297-1994 圆锥滚子轴承30208 Tapered roller bearing 30208 2
21 WHZ1.5-015 转向轮毂 Steering wheel hub 2
22 GB/T297-1994 圆锥滚子轴承30206 Tapered roller bearing 30206 2
23 GB95-2002 垫圈24 Washer 24 2
24 GB9459-1988 六角开槽螺母M24X2 Hexagon grooved nut M24×2 2
25 GB93-1987 弹簧垫圈6 Spring washer 6 4
26 GB5783-86 螺栓M6X15 Bolt M6×15 4
27 JB/7940.2-1999 压注油杯90 Oil cup 4
28 WHZ1.5-016 普通圆柱销A型 Cylindrical pin 2
29 GB95-2002 垫圈12 Washer 12 4
30 GB93-1987 弹簧垫圈12 Spring washer 12 4
31 GB5782-86 螺栓M12X40 Bolt M12×40 4
32 GB5781-2000 螺栓M10X1.25X40 Bolt M10×1.5×40 2
33 GB/T91-2000 销5X45 Pin 5×45 2
34 WHZ1.5-017 轮毂盖 Hub cover 2
35 WHZ1.5-018 轮毂螺栓 Hub nut 12
36 WHZ1.5-019 左转向节 Left steeringknuckle assembly 1
37 LG0030D.03.02-001 减震垫 Rubber gasket 2
44
转向轮/Steer wheel
LG15D(T)
2
6
5
4
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 60205000142 LG0016B.03.06 轮胎总成5.00-8-10PR Tire 5.00-8-10PR 2
2 60205100008 LG0016B.03.07-002 外轮辋3.50D-8 Outer rim 43.50D-8 2
3 60205100007 LG0016B.03.07-001 内轮辋3.50D-8 Inner rim 3.50D-8 2
4 30003111103 30D-0321001 螺栓 Bolt 16
5 51421110115 GB/T97.1 垫圈12 Washer 12 16
6 51401110107 GB/T93 垫圈12 Washer 12 16
7 51307001119 GB/T6170 螺母M12 Nut M12 16
45
油门操纵系统/Throttle control system
LG15D(T)
1
7
6
5
3
4
18
12
11
12
13
4
16 17
19
8
10 20
9 13
14 5
15
46
油门操纵系统/Throttle control system
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 60207030025 30D-0401000 踏板总成 Pedal assembly 1
2 51204081014 GB/T5783 螺栓M6X20 Bolt M6×20 2
3 51401080107 GB/T93 垫圈6 Washer 6 2
4 51307000819 GB/T6170 螺母M6 Nut M6 3
5 51421080115 GB/T97.1 垫圈6 Washer 6 4
6 51204101314 GB/T5783 螺栓M10X35 Bolt M10×35 1
7 51307001019 GB/T6170 螺母M10 Nut M10 1
8 51421090115 GB/T97.1 垫圈8 Washer 8 2
9 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 2
10 51401090107 GB/T93 垫圈8 Washer 8 2
11 30004141001 LG0030D.04.02-001 滚轮 Roller 1
12 51421100115 GB/T97.1 垫圈10 Washer 10 1
13 51512050801 GB/T91 销1.6X16 Pin 1.6×16 4
14 30004018119 LG0015D.04.02.01 支架焊合 Bracket weldment 1
15 51511040602 GB/T882 销B6X16 Pin 6×16 2
16 51204081514 GB/T5783 螺栓M6X45 Bolt M6×45 1
17 30004140100 LG0030D.04.02-002 弹簧 Spring 1
18 30004018120 LG0015D.04.02.02 支架焊合 Bracket weldment 1
19 60980000425 LG0030D.04.03-001 连接叉 Joint 2
20 60207020201 LG0030D.04.03.01 拉索总成 Cable assembly 1
47
熄火操纵系统/Flameout control system
LG15D(T)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 60207020224 LG0030D.05.01 拉索总成 Cable assembly 1
2 51421110115 GB/T97.1 垫圈12 Washer 12 2
48
行车制动系统/Service brake system
LG15D
1
6 4
7 2
3
8
9
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 60980001075 30D-0600001 制动液油杯 Oil cup 1
2 56171000101 JB/T8870 喉箍d16(10~16) Hoop d16(10~16) 2
3 30012187927 LG0030D.06-002 塑料管 Plastic tube 1
4 51309000319 GB/T6171 螺母M10X1.25 Nut M10×1.25 1
5 30006042218 LG0015D.06.04 行车制动总成 Service brake assembly 1
6 51204101214 GB/T5783 螺栓M10X30 Bolt M10×30 4
7 51401100107 GB/T93 垫圈10 Washer 10 4
8 30006013303 LG0015D.06.02 钢管总成 Steel tube assembly 1
9 30006013304 LG0015D.06.03 钢管总成 Steel tube assembly 1
49
行车制动系统/Service brake system
LG15DT
9,10
1
8
4
2
5
11
7
6
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 60980001075 30D-0600001 制动液油杯 Oil cup 1
2 30012187927 LG0030D.06-002 塑料管 Plastic tube 1
3 56171000101 JB/T8870 喉箍d16(10~16) Hoop d16(10~16) 2
4 30006013342 LG0015DT.06.03 钢管总成 Steel tube assembly 1
5 30006013341 LG0015DT.06.02 钢管总成 Steel tube assembly 1
6 51204101114 GB/T5783 螺栓M10X25 Bolt M10×25 4
7 51401100107 GB/T93 垫圈10 Washer 10 4
8 30006042217 LG0015DT.06.01 行车制动总成 Service brake assembly 1
9 51421090115 GB/T97.1 垫圈8 Washer 8 1
10 51512061001 GB/T91 销2X20 Pin 2×20 1
11 51421100115 GB/T97.1 垫圈10 Washer 10 2
50
停车制动系统/Parking brake system
LG15D(T)
4 3 2
右拉索 左拉索
cable cable
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 60208000088 LG0030D.07.01 手制动手柄总成 Parking brake handle 1
2 51421100115 GB/T97.1 垫圈10 Washer 10 2
3 51401100107 GB/T93 垫圈10 Washer 10 2
4 51204101114 GB/T5783 螺栓M10X25 Bolt M10×25 2
51
车架/Chassis
LG15DT
9
12
14
13
制动油杯
Brake oil cup
15
6
7
8
10
11
3 4
1 2
52
车架/Chassis
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51210120115 GB/T5785 螺栓M14X1.5X70 Bolt M14×1.5×70 4
2 51401120107 GB/T93 垫圈14 Washer 14 4
3 51421120115 GB/T97.1 垫圈14 Washer 14 4
4 30008118501 LG0015D.08-001 端盖 End cap 2
5 60980000847 30D-0131400 加油口盖 Oil filler port cap 1
6 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 2
7 51401090107 GB/T93 垫圈8 Washer 8 2
8 51421090115 GB/T97.1 垫圈8 Washer 8 2
9 30008050058 LG0015D.08.G1 车架焊合 Chassis weldment 1
10 56147010601 JB/T982 组合垫圈18 Combination washer 18 2
11 56302000602 JB/ZQ4444 螺塞M18X1.5 Plug M18×1.5 2
12 51341000919 GB/T889.1 螺母M16 Nut M16 4
13 51204135014 GB/T5783 螺栓M16X55 Bolt M16×55 4
14 30008105301 30D-0800024 安装板 Mounting plate 2
15 30008018104 LG0030D.08.07 支架焊合 Bracket weldment 1
53
覆盖件系统/Outer panel system
LG15D(T)
20 31 32
7
21,22,23
19
16,17 25,30
8,9,10,11 18
13 14 35 26,27,28,29,30
12
33
5,6,2
1,2,3
15 34
54
覆盖件系统/Outer panel system
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51204111214 GB/T5783 螺栓M12X30 Bolt M12×30 6
2 51401110107 GB/T93 垫圈12 Washer 12 9
3 51421110115 GB/T97.1 垫圈12 Washer 12 6
4 30009047103 LG0015D.09.01 连接板焊合 Plate 1
5 51420110121 GB/T96.1 垫圈12 Washer 12 3
6 51204111114 GB/T5783 螺栓M12X25 Bolt M12×25 3
7 30009058003 LG0015D.09.02 仪表架焊合 Cabinet 1
8 51204101314 GB/T5783 螺栓M10X35 Bolt M10×35 4
9 51401100107 GB/T93 垫圈10 Washer 10 4
10 51421100115 GB/T97.1 垫圈10 Washer 10 8
11 51307001019 GB/T6170 螺母M10 Nut M10 4
12 60903000019 LG0030D.09-008 工具盒 Tool box 1
13 51158190304 GB/T818 螺钉M6X12 Screw M6×12 2
14 60914010015 LG0015D.09-002 踏板 Pedal 1
15 60980000266 LG0015D.09-003 踏板 Pedal 1
16 30009045943 LG0015D.09.08 底板焊合 Bottom plate weldment 1 LG15D
30009045940 LG0015DT.09.01 底板焊合 Bottom plate weldment 1 LG15DT
17 60914010014 LG0015D.09-001 橡胶垫 Rubber plate 1
18 30009045944 LG0015D.09.09 底板焊合 Bottom plate weldment 1 LG15D
30009045941 LG0015DT.09.02 底板焊合 Bottom plate weldment 1 LG15DT
19 30009046001 LG0015D.09.05 发动机罩总成 Bonnet 1
20 60920011458 LG0030D.09.06 座椅总成 Seat 1
21 51204091214 GB/T5783 螺栓M8X30 Bolt M8×30 4
22 51341000519 GB/T889.1 螺母M8 Nut M8 8
23 51420090121 GB/T96.1 垫圈8 Washer 8 8
24 60923010188 LG0015D.09.07 气弹簧 Air spring 1
25 60701010156 LG0030D.09.08 铰链 Hinge 2
26 51139210505 GB/T70.1 螺钉M8X25 Screw M8×25 4
27 51401090107 GB/T93 垫圈8 Washer 8 4
28 51421090115 GB/T97.1 垫圈8 Washer 8 12
29 51307000919 GB/T6170 螺母M8 Nut M8 6
30 51139210705 GB/T70.1 螺钉M8X35 Bolt M8×35 4
31 30009157300 LG0030D.09-002 螺钉 Screw 2
32 30009157609 LG0015D.09-004 散热器罩 Cover 1
33 30009158001 LG0030D.09-005 橡胶盖 Rubber cap 1
34 60919010181 LG0015D.09-005 密封条 Rubber 1
35 51159190304 GB/T819.1 螺钉M6X12 Screw M6×12 4
55
门架(基本型)/Mast (normal mast)
LG15D(T)
25 10
24 16
11 12 13
15 14
2
1 4
5 3
87
26 9
6
98
7
22,23
21 20
11 19
15 18
17
16
12
13
14
56
门架(基本型)/Mast (normal mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30080080123 LG0016BC.10.05 链条总成LH1223 Chain assembly 2
2 30082185700 LG0030D.10-014 链轮 Chain wheel 2
3 51453350107 GB/T894.1 挡圈40 Snap ring 40 2
4 30080082859 LG0015D.10.01 外门架焊合 Outer mast weldment 1
5 30080081730 LG0016BC.10.02 内门架焊合 Inner mast weldment 1
6 30082025001 LG0030D.10.10 销轴焊合 Pin shaft weldment 2
7 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 3
8 51401090107 GB/T93 垫圈8 Washer 8 3
9 51421090115 GB/T97.1 垫圈8 Washer 8 3
10 30082141003 LG0030D.10-004 滚轮 Roller 2
11 60980000833 LG0030D.10.06.01-002 螺钉M20X1.5X17 Screw M20×1.5×17 4
12 30004141000 LG0030D.10.17-001 滚轮 Roller 4
13 30080180401 LG0030D.10.16-002 防尘片 Dust ring 4
14 51453420107 GB/T894.1 挡圈55 Snap ring 55 4
15 30080182801 LG0030D.10.16-003 止松片 Stop plate 4
16 30082113903 LG0030D.10-020 橡胶垫 Rubber gasket 4
17 30080081404 LG0016BC.10.14-001 滚轮总成760211AT Roller assembly 2
30080081405 LG0016BC.10.14-002 滚轮总成760211A1T Roller assembly 2
30080081406 LG0016BC.10.14-003 滚轮总成760211A1.5T Roller assembly 2
18 51207131814 GB/T5786 螺栓M16X1.5X60 Bolt M16×1.5×60 4
19 51401130107 GB/T93 垫圈16 Washer 16 4
20 30082118500 LG0030D.10-005 端盖 End cap 2
21 30080184500 LG0016BC.10-006 轴衬 Bushing 2
22 56201000301 JB/T7940.1 油杯M10X1 Oil cup M10×1 2
23 60980005823 LG0030D.10-021 红色保护套 Red sheath 2
24 30080185100 LG0016BC.10-001 滑块 Sliding block 2
25 30082154800 LG0030D.10-008 调整垫 Adjusting gasket 2 t0.5
30082154805 LG0030D.10-008 调整垫 Adjusting gasket 2 t1.0
30082154806 LG0030D.10-008 调整垫 Adjusting gasket 2 t2.0
26 30082107800 LG0030D.10-015 管夹 Clip 1
57
门架参数/Parameter(mast)
编 码 起升高度 内门架 外门架 链条编码 链条节数 备 注
Code Lifting H Inner mast Outer mast Code,chain Chain,leaf Remark
30080911080 2000 30080081725 30080082855 30080080116 77
30080911081 2250 30080081726 30080082856 30080080100 85
30080911082 2500 30080081727 30080082857 30080080101 91
30080911083 2750 30080081729 30080082858 30080080138 95
30080911084 3000 30080081730 30080082859 30080080123 101 标准
30080911085 3300 30080081732 30080082860 30080080142 109
30080911086 3500 30080081733 30080082861 30080080140 115
30080911087 3750 30080081737 30080082862 30080080143 121
30080911088 4000 30080081738 30080082863 30080080144 129
30080911089 4250 30080081739 30080082864 30080080145 137
30080911090 4500 30080081740 30080082865 30080080141 143
30080911091 4750 30080081741 30080082866 30080080146 149
30080911092 5000 30080081742 30080082867 30080080112 157
30080911093 5500 30080081743 30080082868 30080080147 171
30080911094 6000 30080081744 30080082869 30080080148 185
58
门架(二级全自由)/Mast(full free 2-stage mast)
LG15D(T)
22 3
21
9
4 5
8 6
7
2
1
10
13
12
11
19,20
17 18
14 16
15
9
4 5 6
8
7
59
门架(二级全自由)/Mast(full free 2-stage mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30080082873 LG0015D.10A.01 外门架焊合 Outer mast weldment 1
2 30080081748 LG0016BC.10A.04 内门架焊合 Inner mast weldment 1
3 30082141003 LG0030D.10-004 滚轮760211BT Roller 2
4 60980000833 LG0030D.10.06.01-002 螺钉M20X1.5X17 Screw M20×1.5×17 4
5 30004141000 LG0030D.10.17-001 滚轮 Roller 4
6 30080180401 LG0030D.10.16-002 防尘片 Dust ring 4
7 51453420107 GB/T894.1 挡圈55 Snap ring 55 4
8 30080182801 LG0030D.10.16-003 止松片 Stop ring 4
9 30082113903 LG0030D.10-020 橡胶垫 Rubber pad 4
10 30082025001 LG0030D.10.10 销轴焊合 Pin shaft weldment 2
11 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 2
12 51401090107 GB/T93 垫圈8 Washer 8 2
13 51421090115 GB/T97.1 垫圈8 Washer 8 2
14 30080081404 LG0016BC.10.14-001 滚轮总成760211AT Roller assembly 2
30080081405 LG0016BC.10.14-002 滚轮总成760211A1T Roller assembly 2
30080081406 LG0016BC.10.14-003 滚轮总成760211A1.5T Roller assembly 2
15 51210131814 GB/T5785 螺栓M16X1.5X60 Bolt M16×1.5×60 4
16 51401130107 GB/T93 垫圈16 Washer 16 4
17 30080184500 LG0016BC.10-006 轴衬 Bushing 2
18 30082118500 LG0030D.10-005 端盖 Cap 2
19 56201000301 JB/T7940.1 油杯M10X1 Fitting M10×1 2
20 60980005823 LG0030D.10-021 红色保护套 Red sheath 2
21 30080185100 LG0016BC.10-001 滑块 Sliding block 2
22 30082154800 LG0030D.10-008 调整垫 Adjusting gasket 2 t0.5
30082154805 LG0030D.10-008 调整垫 Adjusting gasket 2 t1.0
30082154806 LG0030D.10-008 调整垫 Adjusting gasket 2 t2.0
门架参数/Parameter(mast)
编 码 起升高度 内门架 外门架 备 注
Code Lifting H Inner mast Outer mast Remark
30080912040 2000 30080081745 30080082870
30080912041 2500 30080081746 30080082871
30080912042 2750 30080081747 30080082872
30080912043 3000 30080081748 30080082873 标准
30080912044 3300 30080081749 30080082874
30080912045 3500 30080081750 30080082875
30080912046 3750 30080081751 30080082876
30080912047 4000 30080081752 30080082877
30080912049 4500 30080081754 30080082879
60
门架(三级全自由)/Mast(full free 3-stage mast)
LG15D(T)
4
17 10
16 6
5
9 7 8
17 4
16 13 10
6 7 12
8 27
5 29
14 9
28
1
32
26
11
32
1
22,23
20 21
25
19
24 19
18
5
15 9
10
67 15 10
5 8 6
9 78
61
门架(三级全自由)/Mast(full free 3-stage mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 4
2 51401090107 GB/T93 垫圈8 Washer 8 4
3 51421090115 GB/T97.1 垫圈8 Washer 8 4
4 30082141003 LG0030D.10-004 滚轮 Roller 4
5 60980000833 LG0030D.10.06.01-002 螺钉M20X1.5X17 Screw M20×1.5×17 8
6 30004141000 LG0030D.10.17-001 滚轮 Roller 8
7 30080180401 LG0030D.10.16-002 防尘片 Dust ring 8
8 51453420107 GB/T894.1 挡圈55 Snap ring 55 8
9 30080182801 LG0030D.10.16-003 止松片 Stop ring 8
10 30082113903 LG0030D.10-020 橡胶垫 Rubber pad 8
11 30082025001 LG0030D.10.10 销轴焊合 Pin shaft 2
12 30080082878 LG0015D.10B.01 外门架焊合 Outer mast weldment 1
13 30080085315 LG0016BC.10B.03 中门架焊合 Middle mast weldment 1
14 30080081801 LG0016BC.10B.06 内门架焊合 Inner mast weldment 1
15 30080081404 LG0016BC.10.14-001 滚轮总成760211AT Roller assembly 4
30080081405 LG0016BC.10.14-002 滚轮总成760211A1T Roller assembly 4
30080081406 LG0016BC.10.14-003 滚轮总成760211A1.5T Roller assembly 4
16 30080185100 LG0016BC.10-001 滑块 Sliding block 4
17 30082154800 LG0030D.10-008 调整垫 Adjusting gasket 4 0.5mm
30082154805 LG0030D.10-008 调整垫 Adjusting gasket 4 1.0mm
30082154806 LG0030D.10-008 调整垫 Adjusting gasket 4 2.0mm
18 51207131814 GB/T5786 螺栓M16X1.5X60 Bolt M16×1.5×60 4
19 51401130107 GB/T93 垫圈16 Washer 16 8
20 30080184500 LG0016BC.10-006 轴衬 Bushing 2
21 30082118500 LG0030D.10-005 端盖 End cap 2
22 56201000301 JB/T7940.1 油杯M10X1 Oil cup M10×1 2
23 60980005823 LG0030D.10-021 红色保护套 Red sheath 2
24 30080134819 LG0016BC.10B-001 支座 Support seat 2
25 51207131314 GB/T5786 螺栓M16X1.5X35 Bolt M16×1.5×35 4
26 30082107800 LG0030D.10-015 管夹 Clip 2
27 30080080103 LG0016BC.10B.08 链条总成LH1223 Chain assembly 2
28 30082185700 LG0030D.10-014 链轮 Chain wheel 2
29 51453350107 GB/T894.1 挡圈40 Snap ring 40 2
62
门架参数/Parameter(mast)
编 码 起升高度 内门架 中门架 外门架 链条编码 链条节数 备 注
Code Lifting H Inner mast Middle mast Outer mast Code,chain Chain,leaf Remark
30080913006 4000 30080081799 30080085313 30080082880 30080080149 93
30080913007 4350 30080081800 30080085314 30080082881 30080080156 99
30080913008 4500 30080081801 30080085315 30080082878 30080080103 103 标准
30080913009 4800 30080081802 30080085316 30080082882 30080080128 107
30080913010 5000 30080081803 30080085317 30080082883 30080080150 113
30080913011 5400 30080081804 30080085318 30080082889 30080080151 119
30080913012 6000 30080081805 30080085319 30080082890 30080080117 131
30080913013 6500 30080081806 30080085320 30080082723 30080080159 141
63
货叉及货叉架/Fork & fork carrier
LG15D(T)
8 18 17 5
12 15 4
7
16
14 13
9
7 10
6 11
序号 货叉编码 货叉规格 备 注
Item
No Code,fork(1.5T) Model,fork(1.5T) Remark
1 30080081200 920×100×35
2 30080081201 1070×100×35 标准
3 30080081202 1220×100×35
4 30080081203 1370×100×35
5 30080081204 1520×100×35
6 30080081205 1670×100×35
7 30080081206 1820×100×35
8 30080081207 1900×100×35
64
货叉及货叉架/Fork & fork carrier
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30080083500 LG0016BC.10.04 挡货架焊合 Load restrainer weldment 1
2 30080081200 LG0016BC.10.09 货叉总成 Fork 2
3 30080081002 LG0016BC.10.03 货叉架焊合 Fork carrier weldment 1 基本型
65
起升油缸(基本型)/Lift cylinder (normal mast)
LG15D(T)
29
31
30
29
31
30
1
2
45
3
6 1
7 2
8 45
3
9
6
10
7
8
9
11 10
17 12,13 11
23
14 24
15
12,13 17
16 22
25
26
14 20
21
18 28 15
27 16
19
28 18
27
66
起升油缸(基本型)/Lift cylinder (normal mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
A 16600163050 LGG016SP300H 起升油缸 Lift cylinder 2 高度3000
67
起升油缸参数/Lift cylinder parameter
编码 起升高度 活塞杆 缸体 备 注
Code Lifting height Postion rod Cylinder body Remark
68
前起升油缸/Front lift cylinder
LG15D(T)
18
19
17
22
20
1 21
2
34
5
6
7
8
9
10
9
15
26
25
24
23
16 29
13
14 11
12
27
28
69
前起升油缸/Front lift cylinder
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
A 16600276430 LGG016SS435FH 二级前起升油缸 Front lift cylinder 1 二级高度3000
70
前起升油缸参数/Front lifting cylinder parameter
二级全自由
油缸编码 起升高度 活塞杆组件 缸体 链条编码 链条节点 备 注
Code ,cyinder Lifting height Piston rod Cylinder body Code,chain Leaf,chain Remark
16600276130 2000 36600045890 36600016440 30080080161 61
16600276140 2500 36600045900 36600016450 30080080137 75
16600276270 2750 36600046890 36600017520 30080080136 71
16600276430 3000 36600045920 36600016470 30080080116 77 标准
三级全自由
油缸编码 起升高度 活塞杆组件 缸体 链条编码 链条节点 备 注
Code ,cyinder Lifting height Piston rod Cylinder body Code,chain Leaf,chain Remark
16600276270 4000 36600046890 36600018230 30080080120 73
16600276430 4350 36600046900 36600018240 30080080154 79
16600276280 4500 36600046910 36600017520 30080080155 81 标准
71
后起升油缸(二级全自由)/Rear lift cylinder (full free 2-stage mast)
LG15D(T)
32
34
33
32
34
33
15
13 14
10 17
12 9
11 8 16
7 15
6 14
13
5
10
12 9
11 8
7
6
18 19
5
2
3 28
4 29
21 27
20 30
25 31
26
1
22
4
23 24
72
后起升油缸(二级全自由)/Rear lift cylinder (full free 2-stage mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
A 16600162040 LGG016SW300LH 二级后左起升缸 Left lift cylinder 1 高度3000
73
起升油缸参数/Lifting cylinder parameter
左缸 右缸 起升高度 左活塞杆 右活塞杆 左缸体 右缸体
Left lift cylinder Right lift cyinder Lifting height Piston rod,left Piston rod,right Left cylinder body Right cylinder body
16600162010 16600162150 2000 36600046050 36600046190 36600016580 36600016720
16600162020 16600162160 2500 36600046060 36600046200 36600013590 36600016730
16600162030 16600162170 2750 36600046070 36600046210 36600010600 36600016740
16600162040 16600162180 3000 36600046080 36600046220 36600007610 36600016750
16600162050 16600162190 3300 36600046090 36600046230 36600004620 36600016760
16600162060 16600162200 3500 36600046100 36600046240 36600001630 36600016770
16600162070 16600162210 3750 36600046110 36600046250 36599998640 36600016780
16600162080 16600162220 4000 36600046120 36600046260 36599995650 36600016790
16600162100 16600162240 4500 36600046140 36600046280 36599989670 36600016810
16600162090 16600162230 4250 36600046130 36600046270 36599992660 36600016800
16600162110 16600162250 4750 36600046150 36600046290 36599986680 36600016820
16600162120 16600162260 5000 36600046160 36600046300 36599983690 36600016830
16600162130 16600162270 5500 36600046170 36600046310 36599980700 36600016840
16600162140 16600162280 6000 36600046180 36600046320 36599977710 36600016850
74
后起升油缸(三级全自由)/Rear lift cylinder (full free 3-stage mast)
LG15D(T)
34
19 32
20
35
17 33
18 16
15 19
14 20
17
13 18 16
2
3 15 14
13
2
3
5 1
6 12
21
7
8
4 26
25
11 5 24 28
10 27
6
9 7 3130
23
8 29
22
23 9
22
75
后起升油缸(三级全自由)/Rear lift cylinder (full free 3-stage mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
A 16600163320 LGG016SH450LH 三级后左起升缸 Left lift cylinder 1 高 度4 5 0 0
76
起升油缸参数/Lifting cylinder parameter
左缸 右缸 起升高度 活塞杆 左缸体 右缸体 备 注
Left lift cylinder Right lift cyinder Lifting height Piston rod Left cylinder body Right cylinder body Remark
16600163310 16600163360 4000 36600046940 36600017570 36600017620
16600163430 16600163460 4350 36600047450 36600018420 36600018390
16600163320 16600163370 4500 36600046960 36600017580 36600017630 标准
77
倾斜油缸总成/Tilt cylinder assembly
LG15D(T)
6
7 8
9
10 15
11 12 21
13 14 20
19
3
16
4
17
18 22
5
23
27,28
26 2
25
24
78
倾斜油缸总成/Tilt cylinder assembly
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
A 16600017010 LGG015X6/12LH 左倾斜油缸6°/12° Left tilt cylinder 1 6°/12°
79
门架侧移管路(基本型)/Side shifting pipe mast(normal mast)
LG15D(T)
1
4
5 2
6 3
3
12
11 8
9 10
7
11 14
9 10
13
15
16
19 18
910
11
20
19
17
高度
Lifting height 2000 2250 2500 2750 3000 3300 3500 3750
序号12胶管
Hose,NO.12 17272008630 17272008631 17272008632 17272008633 17272008634 17272008635 17272008636 17272008637
高度 4000 4250 4500 4750 5000 5500 6000
Lifting height
序号12胶管
Hose,NO.12 17272008640 17272008641 17272008642 17272008643 17272008644 17272008645 17272008646
备注
Remark
80
门架侧移管路(基本型)/Side shifting pipe mast(normal mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30082185200 LG0025D.10.08-001 滑轮 Pulley 2
2 30082135100 LG0025D.10.08-002 轴套 Sleeve 1
3 30082106403 LG0030D.10.13-002 垫圈 Washer 2 三联2个,四联4个
81
门架侧移管路(二级全自由)/Side shifting pipe mast(full free 2-stage mast)
LG15D(T)
2
1
16
13 21
14 23
15
2
22
21 19
1 20 17
2
18 17
7 12
9
8
15 11
14
12
13 10
24
21
2 23
22 21
5
6 5
3
4
25,26
高度
Lifting height 2000 2500 2750 3000 3300 3500
序 号7导 向 槽
Guide slot,NO.7 30080083800 30080083801 30080083802 30080083803 30080083804 30080083805
序 号1 6导 向 槽 30080184656 30080184657 30080184658 30080184659 30080184660 30080184661
Guide slot,NO.16
序 号2 4胶 管
Hose,NO.24 17272005695 17272005696 17272005697 17272005698 17272005699 17272005700
高度
Lifting height 3750 4000 4500
序 号7导 向 槽
Guide slot,NO.7 30080083806 30080083807 30080083809
序 号1 6导 向 槽
Guide slot,NO.16 30080184662 30080184663 30080184665
序 号2 4胶 管 17272005701 17272005702 17272005704
Hose,NO.24
82
门架侧移管路(二级全自由)/Side shifting pipe mast(full free 2-stage mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51204080914 GB/T5783 螺栓M6X16 Bolt M6×16 6 四联12件
2 51401080107 GB/T93 垫圈6 Washer 6 10 四联20件
3 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 2
4 51401090107 GB/T93 垫圈8 Washer 8 2
5 17272005159 LG0016BC.10A.02.01 胶管总成 Hose assembly 2 四联4件
83
门架侧移管路(三级全自由)/Side shifting pipe mast(full free 3-stage mast)
LG15D(T)
4
33
3 5 34
2 14
1 36
13
12 37
2
38
6
35
7
40
4
8 39
41 21
9
29
30
31
14 32 10
13 22
12
16 1311 16
18 18
17 17
19
18 19
18
20 15
15 20
28 22
23
24 23
22 22
25 12 23
26 13 27
14
高度
Lifting height 4000 4350 4500 4800 5000 5400 6000 6500
序 号6胶 管
Hose,NO.6 17272009549 17272009557 17272009550 17272009551 17272009552 17272009553 17272009554 17272009555
序 号2 1胶 管
Hose,NO.21 17272009557 17272009558 17272009559 17272009552 17272009553 17272009560 17272009561 17272009562
序 号2 9胶 管
Hose,NO.29 17272009549 17272009563 17272009564 17272009557 17272009550 17272010118 17272009559 17272009552
84
门架侧移管路(三级全自由)/Side shifting pipe mast(full free 3-stage mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51203112018 GB/T5783 螺栓M12X70 Bolt M12×70 1
2 51401110107 GB/T93 垫圈12 Washer 12 1
3 51420110121 GB/T96.1 垫圈12 Washer 12 1
4 30080185200 LG0016BC.10A.02-003 滑轮 Pulley 4 四联6件
85
门架起升管路(二级全自由)/Lift pipe mast(full free 2-stage mast)
LG15D(T)
34
2
限速阀
9 10
6 6
87
门架起升管路(三级全自由)/Lift pipe mast(full free 3-stage mast)
LG15D(T)
4
5
3
2
1
10
11
15 13
26 12
7
8
9
21
25
14
21
11 22 23
17
18
20
19
16
24
高度
Lifting height 4000 4350 4500 4800 5000 5400
序号6胶管
Hose,NO.6 17272009403 17272009546 17272009462 17272008801 17272009336 17272009547
高度
Lifting height 6000 6500
序号6胶管 17272009548 17272008546
Hose,NO.6
备注
Remark
88
门架起升管路(三级全自由)/Lift pipe mast(full free 3-stage mast)
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 51210120215 GB/T5785 螺栓M14X1.5X50 Bolt M14×1.5×50 1
2 51401120107 GB/T93 垫圈14 Washer 14 1
3 51421120115 GB/T97.1 垫圈14 Washer 14 1
4 30080185203 LG0016BC.10B.10-001 滑轮 Pulley 1
5 30082135103 LG0016BC.10B.10-002 轴套 Sleeve 1
6 17272009462 LG0016BC.10B.10.01 胶管总成 Hose assembly 1 高度4500
89
多路阀操纵/Multi - way valve control
LG15D(T)
9
7
5
10
8 3
6 1
13
12
14
15 19
18
20
21
15
13 11 22
17
16
多路阀
90
多路阀操纵/Multi-way valve control
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 60207010080 LG0030D.11-001 手柄总成 Handle assembly 1
2 30011020620 LG0030D.11.01 操纵杆焊合 Control lever weldment 1
3 60207010081 LG0030D.11-002 手柄总成 Handle assembly 1
4 30011020621 LG0030D.11.02 操纵杆焊合 Control lever weldment 1
5 60207010082 LG0030D.11-003 手柄总成 Handle assembly 1 三联多路阀用
6 30011020622 LG0030D.11.03 操纵杆焊合 Control lever weldment 1 三联多路阀用
7 60207010083 LG0030D.11-004 手柄总成 Handle assembly 1 四联多路阀用
8 30011020623 LG0030D.11.04 操纵杆焊合 Control lever weldment 1 四联多路阀用
9 60207010094 LG0030D.11-008 手柄总成 Handle assembly 1 五联多路阀用
10 30011020600 LG0030D.11.11 操纵杆焊合 Control lever weldment 1 五联多路阀用
11 30011115008 LG0030D.11-005 支架 Bracket 1 两联多路阀用
30011115009 LG0030D.11-006 支架 Bracket 1 三联多路阀用
30011115010 LG0030D.11-007 支架 Bracket 1 四联多路阀用
30011115001 LG0030D.11-010 支架 Bracket 1 五联多路阀用
12 30011025014 LG0030D.11.05 销轴焊合 Pin shaft weldment 1 两联多路阀用
30011025015 LG0030D.11.06 销轴焊合 Pin shaft weldment 1 三联多路阀用
30011025016 LG0030D.11.07 销轴焊合 Pin shaft weldment 1 四联多路阀用
30011025001 LG0030D.11.10 销轴焊合 Pin shaft weldment 1 五联多路阀用
13 51204090914 GB/T5783 螺栓M8X16 Screw M8×16 5
14 51401090107 GB/T93 垫圈8 Washer 8 1
15 51421090115 GB/T97.1 垫圈8 Washer 8 5
16 60905000023 30D-1100004 销轴 Pin 2 三联3个/四联4个
17 51512061001 GB/T91 销2X20 Pin 2×20 2 三联3个/四联4个
18 51511051102 GB/T882 销B8X26 Pin 8×26 2 三联3个/四联4个
19 51512071201 GB/T91 销2.5X25 Pin 2.5×25 2 三联3个/四联4个
20 30011141801 LG0030D.11.08-002 连接叉 Connecting fork 2 三联3个/四联4个
21 51307000919 GB/T6170 螺母M8 Nut M8 2 三联3个/四联4个
22 30011117505 LG0030D.11.08-001 连接杆 Connecting rod 2 三联3个/四联4个
91
液压系统/Hydraulic system
LG15D(T)
22
14
13
28,29
21
17
18
15 31
30
9 12 39 45 32
1110
8 910 16
44
43
33 23
21
4 36
39
42
20 接油箱回油管 38
40
41 39 27 25 26
4 37
2 42 25 26
1 接油箱回油管
46
48 24
2 接油箱回油管
1
35
34
6
7
47
19
49
4
5
50 4
3
51
52
92
液压系统/Hydraulic system
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 68080000004 20B-1202016 扎带5X350 Binding tape 5×350 4
2 60911010924 LG0030D.12-020 回油管布夹 Oil return cloth clip 4
3 30080187902 LG0016BE.10.02-005 回油管 Oil return hose 2
4 56171000101 JB/T8870 喉箍d16(10~16) Hoop d16(10~16) 5
5 30080116706 LG0015B.12-021 三通接头 T-connector 1
6 30012187937 30D-1200017 塑料管 Plastic tube 1
7 60304000075 LG0016B.12.06 限速阀 Speed limit valve 1
8 51207105314 GB/T5786 螺栓M10X1.25X35 Bolt M10×1.25×35 3
9 51420100121 GB/T96.1 垫圈10 Washer 10 6
10 30012113903 LG0030D.12-018 橡胶垫 Rubber 6
11 30012112300 LG0030D.12-019 套管 Casing 3
12 60911010956 20D-1201000 多路阀 Multi-way valve 1 两片
多路阀 四片
60911010958 20D-1203000 Multi-way valve 1
13 17601000183 30D-1206000 过渡接头 Adapter 4
14 17272009688 LG0015D.12-020 胶管总成 Hose assembly 2
15 17272005603 LG0015D.12-005 胶管总成 Hose assembly 2
16 30012013312 LG0030D.12.08 钢管总成 Hose assembly 1
17 51204091114 GB/T5783 螺栓M8X25 Bolt M8×25 2
18 51421090115 GB/T97.1 垫圈8 Washer 8 2
19 51401090107 GB/T93 垫圈8 Washer 8 1
20 30012187924 LG0030D.12-011 回油管 Oil return hose 1
21 56171000601 JB/T8870 喉箍d50(32~50) Hoop d50(32~50) 4
22 30012073013 LG0015D.12.06 液压油箱盖板总成 Oil tank cover plate 1
23 30012106016 LG0015D.12-021 成型管 Molding pipe 1
24 17272005605 LG0015D.12-009 胶管总成 Hose assembly 1
25 17601000218 LG0030D.12.10-005 过渡接头 Adapter 2
26 56905000504 ISO3601-1 O形圈13.3X2.4 O-ring 13.3×2.4 2
27 17272005606 LG0015D.12-010 胶管总成 Hose assembly 1
28 30012134901 LG0015D.12-013 纸垫 Gasket 1
29 60301000395 LG0015D.12.10 齿轮泵 Pump 1
30 17601000141 30D-1200024 过渡接头 Adapter 1
31 56145005101 GB/T3452.1 O形圈18X2.65 O-ring 18×2.65 1
32 30012008310 LG0015D.12.11 过渡接头 Transition connector 1
33 17272009603 LG0030DTDAⅢ.12-004 胶管总成 Hose assembly 1
34 30012187919 LG0030B.12-006 回油管 Oil return hose 1
93
液压系统/Hydraulic system
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
35 56171002301 JB/T8870 喉箍d25(16~25) Hoop d25(16~25) 2
36 60305000023 BZZ1-E100BA-H 转向器 Steering gear 1
37 17272000955 30D-1200012 胶管总成 Hose assembly 1
38 17601000240 30D-1200002 过渡接头 Transition connector 1
39 56145004805 GB/T3452.1 O形圈17X2.65 O-ring 17×2.65 5
40 37201000202 30D-1200003 软管接头 Hose connector 1
41 17601000286 30D-1204000 过渡接头 Transition connector 1
42 17601000221 LG0030D.12.10-006 过渡接头 Transition connector 2
43 17601000300 30D-1215000 过渡接头 Transition connector 1
44 17601000296 30D-1216000 过渡接头 Transition connector 1
45 17601000212 30D-1200001 过渡接头 Transition connector 2
46 56171001301 JB/T8870 喉箍d20(12~20) Hoop d20(12~20) 1
47 51204091314 GB/T5783 螺栓M8X35 Bolt M8×35 1
48 17272002126 LG0016BC.10.06 胶管总成 Hose assembly 1 基本型门架用
94
液压油箱盖板总成/Hydraulic oil tank cover plate
LG15D(T)
1 6
7
3 8
4
2
10
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30012026201 30D-1211001 油尺总成 Oil dipstick assembly 1
2 30012072824 LG0015D.12.06.02 液压油箱盖板焊合 Oil tank cover plate 1
3 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 8
4 60980000546 30D-0131006 垫圈8 Washer 8 8
5 30001111512 LG0015D.01.03-001 密封垫 Seal gasket 1
6 30012071501 LG0060DT.12.11.03 呼吸器总成 Breather 1
7 30012109203 LG0060DT.12.11-001 塑料管 Hose 1
8 56171000101 JB/T8870 喉箍d16(10~16) Hoop d16(10~16) 2
9 30012015102 LG0060DT.12.11.04 滤油器总成 Oil filter assembly 1
10 60980000538 20B-1206005 磁铁50X25X8 Magnet 50×25×8 1
95
护顶架/Overhead guard
LG15D(T)
18
17
11 16
19
20 15 14
4 5
10 6
13
21
12
22
17 18
16
24
3
23
4 5
6
7 8 9
1 2
96
护顶架/Overhead guard
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30014113900 LG0030D.14-008 橡胶垫 Rubber pad 2
2 30014113901 LG0030D.14-010 橡胶垫 Rubber pad 2
3 30014057504 LG0015D.14.01 立柱焊合 Stand column weldment 1
4 51204111114 GB/T5783 螺栓M12X25 Bolt M12×25 6
5 51401110107 GB/T93 垫圈12 Washer 12 6
6 51421110115 GB/T97.1 垫圈12 Washer 12 6
7 30014111103 LG0030D.14-006 螺栓 Bolt 2
8 51401130107 GB/T93 垫圈16 Washer 16 2
9 30014106400 LG0030D.14-007 垫圈 Washer 2
10 30014057505 LG0015D.14.02 立柱焊合 Stand column weldment 1
11 30014058501 LG0015D.14.03 护顶架焊合 Overhead guard 1
12 60917010007 LG0030D.14-001 倒车镜 Rearview mirror 1
13 30014115019 LG0030D.14-002 支架 Bracket 1
14 51204091014 GB/T5783 螺栓M8X20 Bolt M8×20 1
15 51401090107 GB/T93 垫圈8 Washer 8 1
16 51158190304 GB/T818 螺钉M6X12 Screw M6×12 6
17 51401080107 GB/T93 垫圈6 Washer 6 6
18 51421080115 GB/T97.1 垫圈6 Washer 6 6
19 30014168800 LG0030D.14-003 进气罩 Cover 1
20 30014018102 LG0030D.14.03 支架焊合 Bracket 1
21 30014018103 LG0030D.14.04 支架焊合 Bracket 1
22 60980000270 30D-0900011 过线圈 Rubber ring 6
23 30009156200 20B-0900001 把手 Handle 2
24 51139190605 GB/T70.1 螺钉M6X25 Screw M6×25 4
97
电气系统/Electric system
LG15D(T)
11
12,41
10
9
13
8
3,4,5,6,7,40
16,19,20
17 18
1,2
21,22,26,27
油压报警开关
水温传感器
20110715000001
+ -
21,22,27,37 36 35 34 32 33 28,29,30,31
98
电气系统/Electric system
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30015067604 LG0030DT.15.01 线束总成 Harness assembly 1
2 60980005598 LG0030DⅢ.15-003 扎带 Binding tape 13
3 30015163414 LG0030DT.15-001 仪表总成 Combination instruction 1
4 51204081214 GB/T5783 螺栓M6X30 Bolt M6×30 4
5 51430080114 GB/T5287 垫圈6 Washer 6 4
6 60405020047 LG0030D.15-003 组合开关 Combination switch 1 LG15D
7 60405020128 LG0030D.15-005 警示灯开关 Warning lamp switch 1
8 30015064508 LG0030DT.15.03 护顶架线束 Wiring harness 2
9 30015064200 LG0030D.15.01 工作灯 Working lamp 3
10 30015067101 LG0030D.15.02 前组合灯 Front combination lamp 2
11 30015064403 LG0030B.15.19 警示灯 Warning lamp 1 选配
99
标牌/Label
LG15D(T)
2 5 2
1 1
17
3 3
7 6 7
9 9
2
14,15
19 18 (贴于安全架后横梁后面中间)
D向 16
(贴于门架中横梁反面中间)
100
标牌/Label
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30016197312 LG0030D.16-001 警示标牌货叉上下禁止停留 No stay label 2
2 30016197802 LG0030D.16-002 起吊点标牌 Hoisting point label 4
3 30016197506 LG0030D.16-003 龙工标志 Lonking label 2
4 30016197604 LG0030D.16-004 轮胎气压标牌 Tire pressure label 1
5 30016197101 LG0030D.16-005 叉车吊运标牌 lifting and transportation label 1
6 30016198503 LG0030D.16-006 油品标牌 Oil label 1
7 30016198267 LG0015D.16-001 型号标牌 Model label 2 LG15D
101
平衡重/Counter weight
LG15D(T)
2
2
3
4
5
1,7
序号 编 码 图 号 零部件名称 数量 备 注
Item
No Code Part No Description Q'ty Remark
1 30017151506 LG0015D.17-001 平衡重 Counter weight 1 出口
102