Professional Documents
Culture Documents
Additional Wiring
Theory Of Operation
The Occupant Restraint Controller module (ORC) receives power from both a battery and ignition fed input
circuit from the Totally Integrated Power Module (TIPM). These circuits power the ORC and the capacitors
used to initiate the squib deployment circuits in the event of collision detection.
Monitor Conditions
When Monitored:
The Occupant Restraint Module (ORC) monitors the battery voltage and ignition continuously.
Set Conditions
Set Condition:
This code is set immediately after the Occupant Restraint Module (ORC) detects that voltage on the
battery voltage supply circuit is 17.45 ± 1.45 volts or more for greater than 15 seconds.
Possible Causes
Possible Causes
CHARGING SYSTEM VOLTAGE HIGH
TOTALLY INTEGRATED CONTROL MODULE (TIPM)
OCCUPANT RESTRAINT CONTROLLER (ORC)
Always perform the Pre-Diagnostic Troubleshooting procedure before proceeding. See DTC-Based
Diagnostics/CONTROLLER, Occupant Restraint (ORC) - Standard Procedure.
Diagnostic Test
Are there any Charging System DTCs set in the Powertrain/Engine Control Module?
Yes
No
Go to step 2
Go to step 3
viernes, 12 de julio de 2019 17:26:20 Page 2 © 2011 Mitchell Repair Information Company, LLC.
2009 Dodge Journey R/T
2009 RESTRAINTS Electrical Diagnostics - Journey
WARNING: Turn the ignition off disconnect the 12-volt battery and wait two
minutes before proceeding. Failure to follow these instructions
may result in possible serious or fatal injury.
2. Connect the Load Tool ORC 8443-28 Adaptor to the ORC connectors.
WARNING: Turn the ignition on, then reconnect the 12-volt battery. Wait
two minutes before proceeding. Failure to follow these
instructions may result in possible serious or fatal injury.
3. Measure the voltage of the (A27) Fused B+ circuit between the Load Tool ORC 8443-28
Adaptor and ground.
Yes
WARNING: Turn the ignition off disconnect the 12-volt battery and
wait two minutes before proceeding. Failure to follow
these instructions may result in possible serious or
fatal injury.
Repair the (A27) Fused B+ circuit and the (F201) Fused Run/Start Relay Output circuit.
Perform RESTRAINTS SYSTEM VERIFICATION TEST. See DTC-Based
Diagnostics/CONTROLLER, Occupant Restraint (ORC) - Standard Procedure.
No
WARNING: Turn the ignition off disconnect the 12-volt battery and
wait two minutes before proceeding. Failure to follow
these instructions may result in possible serious or
fatal injury.
viernes, 12 de julio de 2019 17:26:20 Page 3 © 2011 Mitchell Repair Information Company, LLC.
2009 Dodge Journey R/T
2009 RESTRAINTS Electrical Diagnostics - Journey
viernes, 12 de julio de 2019 17:26:20 Page 4 © 2011 Mitchell Repair Information Company, LLC.