Vidyarthiplus Important Questions
‘Anna University, Chennai
Department of B.£-Electronics and Instrumentation Engineering
B.E / B.TECH DEGREE EXAMINATION Nov Dec 2015,
SEVENTH SEMESTER
£12402 Logic and Distributed Control System
{REGULATION 2008)
11, Explain the basic architecture of PLC with neat block diagram.
2, Explain the principle of operation of discrete ac input and output modules used in PLC
with suitable diagrams.
3. Explain Retentive on delay timer instructions in a PLC with example.
4. Explain up-counter instructions in a PLC with example
5, Write a program that will cause a light to come on if a PLC counter value is less than 10
or more than 30.
6. Explain the data manipulati
7, Construct a non-retentive timer program that will turn on a pilot light after a time delay
period. Use a thumbwheel switch to vary the preset time-delay value of the timer.
8. Explain program control instructions used In PLC
9, Explain in detail about Direct Digital Control.
10. Explai
detail about Data Aqusition system.
11, Distinguish between SCADA and DCS, Explain the hardware architecture of SCADA
12. Explain the DDC with Neat Diagram
13, Explain the block diagram and flowchart of Computer Controlled System (CCS), also
‘mention about the protocols used In CCS
14.£xplain in detail about SCADA and write down its applications
.15.Explain process interfacing issues in LCU.
16. Explain in detail about secure control output configuration,
17. Explain in detail about low level engineering interfaces.
18, Explain General purpose computers in DCS.
19, Explain about the operator displays.20. Mention the adv of low level and high level operator interfaces. Also explain theimportance
operator display used in process industry.