Professional Documents
Culture Documents
GTX Series
Industrial Grade UPS for Critical Application
GTX 2.25 VA
GTX 3.35 VA
GTX 1.15 KVA
LCD Display Panel Accessories
MODEL NEUTRON 650 NEUTRON 1250
SNMP Card AS-400 Card Mantenance Bypass
Switch/PDU
CAPACITY VA/W 650VA 1250VA
Voltage 110/120 VAC or 220/230/240VAC
INPUT
Voltage Range 81-145VAC or 162-290VAC
Voltage 110/120 VAC or 220/230/240VAC
Voltage Regulation
(Battery Mode) +/-10%
OUTPUT
EW GTX
FrequencyNRegulation SERIES SPECIFICATION
(Batt. Mode) 50Hz or 60Hz ± 1 Hz
MODEL GTX 1.150 VA GTX 2.250 VA GTX 3.350 VA
CAPACITY* Output Waveform 1150 VA 2250 VA
Simulated Sine Wave 3350 VA
INPUT
Battery Ty
Low Line Transfer pe & Number*
160VAC/140VAC/120VAC/110VAC±5%
12V7Ah x 1pc or 80VAC/70VAC/60VAC/50VAC±5%
12V7Ah x 2pcs
( based on load percentage 100% - 80 % / 80 % - 70 % / 70 - 60 % / 60 % - 0)
Voltage
BATTERYLow LineBack
Range up Time
Comeback Up to 15 minutes
175 VAC ± 5 % or 85 VAC ± 5 %Up to 30 minutes
High Line Transfer 300 VAC ± 5 % or 150 VAC ± 5 %
High Line Comeback 290 VAC ± 5 % or 145 VAC ± 5 %
Frequency Range
Recharge Time 4-6 hours to 90% after complete discharge
40Hz ~ 70 Hz 8 hours recover to 90% capacity
Phase Single phase with ground
Power Factor
AC Mode Green
≧ 0.99 @ 220-230 VAClighting
(input voltage)
OUTPUT
INDICATOR Battery Mode Yellow flashing
Output voltage 208/220/230/240VAC or 110/115/120/127 VAC
AC Voltage Regulation
Fault Red Mode)
± 3% (Batt. lighting
Frequency Range
47 ~ 53 Hz or 57 ~ 63 Hz
TRANSFER
(SynchronizedTIME
Range)Typical 4-6ms
Frequency Range (Batt. Mode) 50 Hz ± 0.25 Hz or 60Hz ± 0.3 Hz
Current Crest Ratio Phone/fax/DSL/Network 3:1
Surge Protection ≦ 3 % THD RJ-11 (One In One Out)
(Linear Load) ≦ 4 %RJ-45 (One In One Out)
THD (Linear Load)
Harmonic Distortion
≦ 6 % THD (Non-linear Load) ≦ 7 % THD (Non-linear Load)
PROTECTION EMI/RFI Filter Full time
Waveform (Batt. Mode) Pure Sinewave
EFFICIENCY
AC Mode AC Input ~ 85% Circuit breaker ~ 88%
Green ECO Mode ~ 97%
BATTERY Full Protection Overcharge and Overload Protection
Battery Type 12 V / 7 AH 12 V / 7 AH 12 V / 9 AH
NumbersDimension DxWxH (mm) 330 x 100 x 145
3/4(extended) 6/8(extended) 350 x 146 6/8(extended)
x 160
PHYSICAL
Standard
Recharge Time 4 hours recover to 90% capacity (Typical)
Model Net Wei ght (kgs)
Charging Current 5.0 1.0 A(max.) 8.0
Charging Voltage
Operating Environment41.0/54.6 VDC ± 1% 0-90Depending
Battery Type % RH @on
82.1/109.4 VDC ±1%
0-applications
40°C (non-condensing)
Long-run
ENVIRONMEN Numbers 3/4(extended) 6/8(extended)
Model
T Noise Level
Charging Current 4.0 ALess
or 8.0than 40dB
A (max.)
Charging Voltage 41.0/54.6 VDC ± 1% 82.1/109.4 VDC ±1%
INTERFACE
PHYSICAL USB Windows 98 SE/ME/NT 4.x/2000/2003/XP/Vista/2008
Standard Dimension, DXWXH (mm) 397X145X220 421X190X318
* Model
Product specifications are subject to change without
Net Weight (kgs) 13.2 further
/ 16.2 notice 26.0 /32.0 28.6 / 35.6
Dimension, DXWXH
Long-run 397X145X220 421X190X318
(mm)
Model
Net Weight (kgs) 6.9 / 9.9 13.0 / 16.0 15.0 / 22.0
ENVIRONMENT
Operation Temperature 0- 40°C (the battery life will down when > 25°C)
Operation Humidity 20-90 % RH @ 0- 40°C (non-condensing)
Operation Altitude** <1000m
Acoustic Noise Level Less than 45dBA @ 1 Meter
MANAGEMENT
Smart RS-232 or USB Supports Windows® 98/2000/2003/XP/Vista/2008, Windows® 7, Linux, and MAC
Optional SNMP Power management from SNMP manager and web browser
* Derate capacity to 60% of capacity in CVCF mode and to 90% when the output voltage is adjusted to 208VAC.
**If the UPS is installed or used in a place where the altitude is above than 1000m, the output power must be derated one percent per 100m.
***Product specifications are subject to change without further notice.