Professional Documents
Culture Documents
-
Modbus Slave
Copyright (c) Witte Software. 2002-2017.
-----------------------------------------------------------------------------------
-
Getting started:
-----------------------------
1. Press F3 to setup a connection.
2. Press F8 to setup protocol definition.
Example:
You want to simulate 20 holding registers from address 40011 (10).
- Slave ID = The ID of your device
- Function = 03 Read Holding Registers
- Address = 10 (Protocol address)
- Quantity = 20
Note:
In Windows it is not possible to measure the 3.5 character
idle time between two Modbus frames. That means that it may not
be possible to use Modbus Slave in parallel with another
slave device unless you are sure that the delay in the slave
is > 20ms.
Order information:
--------------------------
Visit http://www.modbustools.com
Technical Support:
--------------------------
Your feedback is very important for the further development
of Modbus Slave. For bug reports, comments, suggestions or
complaints, please find contact information at
http://www.modbustools.com