Professional Documents
Culture Documents
Via Friuli, 6
36015 SCHIO (Vicenza) - Italia
Phone: +39 0445 697411
Fax: +39 0445 697414
www.videotec.com
Release Notes
Firmware Videoencoder
Upgrade Pack
Release: 1.4.3
Preface
2. Compatible products
Release Products
1.4.3 UC_DeLux, NXPTZ_DeLux, MMX, MPX_DeLux
1.4.0 UC_DeLux, NXPTZ_DeLux, MMX, MPX_DeLux
1.2.1 UC_DeLux, NXPTZ_DeLux, MMX
1.2.0 UC_DeLux
1.0.1 MMX
4. Removed Features
Release Feature Description
None None
5. Behaviour Changes
© Videotec S.p.A. 3 (5)
Release Feature Description
None None
7. Resolved Issues
Release Description
1.4.3 Autofocus problem after camera default with MMX-10x
I-frame is set wrongly when the codec is switched from H264 to
MPEG4 and vice versa
ONVIF AbsoluteMove request with only zoom parameter set moves
pan-tilt to zero position, vice versa with only pan-tilt parameters set
the zoom is moved to zero
1.4.0 Device was not reachable using IPv6 when there was at least one
user defined
1.2.1 Javascript problems with IE11
1.2.0 Anti-lockout policy for user management
8. References
None.
The information in this document is subject to change without notice and describes only
the product defined in the introduction of this documentation. This documentation is
intended for the use of Videotec S.p.A. customers only for the purposes of the agreement
under which the document is submitted, and no part of it may be used, reproduced,
modified or transmitted in any form or means without the prior written permission of
Videotec S.p.A. The documentation has been prepared to be used by professional and
properly trained personnel, and the customer assumes full responsibility when using it.
Videotec S.p.A. welcomes customer comments as part of the process of continuous
development and improvement of the documentation.
This documentation and the product it describes are considered protected by copyrights
and other intellectual property rights according to the applicable laws.