Professional Documents
Culture Documents
2001 KIA
Rio
CONTROL UNITS
CONTROL UNITS LOCATION
Component Component Location
ABS Unit At left rear of engine compartment.
Air Bag Unit Under front of center floor console. See Fig. 2 .
DRL Unit Behind left end of dash. See Fig. 2 .
Engine Control Module Behind left kick panel. See Fig. 2 .
Flasher Unit Behind left end of dash. See Fig. 2 .
Shift Lock Unit At base of selector lever.
Sound Warning Unit Behind left end of dash.
Transmission Control Module Behind left kick panel. See Fig. 2 .
MOTORS
MOTORS LOCATION
Component Component Location
Blower Motor Behind right side of dash, on bottom of HVAC assembly.
Condenser Fan Motor Behind right side of radiator.
Cooling Fan Motor Behind left side of radiator.
Front Washer Motor On bottom of washer reservoir.
Front Wiper Motor On left side of firewall.
Fuel Pump Unit On top of fuel tank, under rear seat.
SWITCHES
SWITCHES LOCATION
Component Component Location
Back-Up Lamp Switch (M/T) On transaxle rear cover.
Brake Fluid Switch On brake fluid reservoir.
Dual Pressure Switch At right front of engine compartment. See Fig. 1 .
Oil Pressure Switch On right side of engine block, forward of oil filter. See
Fig. 1 .
Parking Brake Switch At base of parking brake lever.
Power Steering Pressure Switch At front of engine, on power steering oil pump. See
Fig. 1 .
Starter Clutch Pedal Position Above clutch pedal. See Fig. 2 .
Switch
Stoplight Switch Above brake pedal. See Fig. 2 .
Transmission Range Switch On top left of transaxle.
MISCELLANEOUS
MISCELLANEOUS LOCATION
Component Component Location
Condenser Near top rear of engine.
Diagnosis Connector At left side of engine compartment. See Fig. 1 .
OBD II Connector Under left side of dash.
Resistor Behind right side of dash.
CONNECTORS
CONNECTORS LOCATION
Component Component Location
X04 (22 Pin) At left side of engine compartment, near main fuse box. See Fig. 1 .
X05 (17 Pin) At left side of engine compartment, near main fuse box. See Fig. 1 .
X06 (17 Pin) At left side of engine compartment, near main fuse box. See Fig. 1 .
X07 (22 Pin) Behind right side of dash, above right kick panel. See Fig. 2 .
X08 (22 Pin) Behind left kick panel. See Fig. 2 .
X09 (22 Pin) Behind left kick panel. See Fig. 2 .
X10 (17 Pin) Behind left kick panel. See Fig. 2 .
X11 (12 Pin) At left side of engine compartment.
X12 (12 Pin) At left side of engine compartment, near battery. See Fig. 1 .
X13 (12 Pin) At right rear top of engine. See Fig. 1 .
X14 (8 Pin) At left front of engine compartment. See Fig. 1 .
X15 (2 Pin) Behind left "A" pillar. See Fig. 2 .
X16 (21 Pin) Behind left side of dash. See Fig. 2 .
X18 (21 Pin) Behind right "A" pillar. See Fig. 2 .
X20 (20 Pin) Behind left kick panel.
X21 (16 Pin) Behind left kick panel.
GROUNDS
GROUNDS LOCATION
Component Component Location
G1 Behind right side of dash, below "A" pillar. See Fig. 2 .
G2 Behind right side of dash, below "A" pillar. See Fig. 2 .
G3 Behind left side of dash, below "A" pillar. See Fig. 2 .
G4 Behind left side of dash, below "A" pillar. See Fig. 2 .
G6 Below center console. See Fig. 2 .
G7 Behind center of dash.
G8 Behind center of dash.
G10 Under left "B" pillar.
G11 At rear of luggage compartment.
G14 Under battery. See Fig. 1 .
G15 At right front of engine compartment, on inner fender panel. See Fig. 1 .
G16 At right front of engine compartment, on inner fender panel. See Fig. 1 .
G17 At left front of engine compartment. See Fig. 1 .
NOTE: Figures may show multiple component locations. Refer to appropriate table for
proper figure references.
Fig. 2: Dash
Courtesy of KIA MOTORS AMERICA, INC.