Professional Documents
Culture Documents
Page 1
06-LOEP Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Page 1
06-CONTENTS Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
1. GENERAL
This chapter provides dimensions, stations and zone illustrations to aid maintenance personnel in locating
various components on the airplane as referenced elsewhere in this manual.
This Chapter is broken down in several sub-system/sections. The following is a list of the information
contained in this Chapter.
06-10-00 - Airplane Dimensions
06-30-00 - Station Locations
06-50-00 - Fuselage Access Panels
Page 1
06-00-00 Nov 1/10
MODEL 1900D AIRLINER MAINTENANCE MANUAL
1. GENERAL
The major dimensions of the airplane are shown in Figure 1.
Figure 1
Airplane Dimensions
Page 1
06-10-00 Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
1. GENERAL
This chapter provides airplane station illustration to aid maintenance personnel in locating various
components on the airplane as referenced elsewhere in this manual.
Page 1
06-30-00 Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Page 2
Nov 1/10 06-30-00
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Figure 1
Stations Diagram
Page 3
06-30-00 Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
1. ACCESS OPENINGS
Figures 201 thru 206 provide illustrations of the access openings of the airplane.
Page 1
06-50-00 Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Figure 1
Floorboard Access Openings (U-1 thru U-164, except U-50)
Page 2
Nov 1/10 06-50-00
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Figure 2
Floorboard Access Openings (U-50, U-165 and After)
Page 3
06-50-00 Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Figure 3
Fuselage Access Openings
Page 4
Nov 1/10 06-50-00
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Page 5
06-50-00 Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Figure 4 (Sheet 1 of 2)
Wing Center Section Access Openings (U-1 thru U-164, except U-50)
Page 6
Nov 1/10 06-50-00
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
1. Nacelle Fuel Cell Filler Neck and Tank Unit 16. Primary and Secondary Boost Pumps,
(Not on A99A) Drain Manifold and Fuel Cell
2. Fuel Line 17. Rear Nacelle
3. Fire Extinguisher Lines, Fuel Tank 18. Inverter
Connector Lines and Wing Electrical
Connectors
4. Inverter 19. Main Landing Gear Points
5. Aileron and Aileron Tab Cable 20. Fuel Line Connections
6. 44 Gallon Fuel Cell 21. Inboard Flap Actuators
7. Inboard Flap Actuator 22. Aileron Cables
8. Fuel Tank Unit 23. 44 Gallon Fuel Cell
9. External Power Receptacle (Prior to U-89), 24. Fuel Strainer and Drain
Fuel Line Check Valve and Wing Electrical
Connectors
10. Fuel Line, Fuel Purge Valve, Fire 25. Engine Access
Extinguisher Lines and Engine Control
Cables
11. Bleed Air Lines and Firewall Shutoff Valve 26. Landing Gear Retract Universal Bearings.
RH Side Only - Emergency Fuel Fuse
Panel. LH Side Only - Heater Fuel Pump,
Fuel Shutoff Valve, Pressure Regulator
and Strobe Light Power Unit
12. Starter Relays, External Power Relay (RH 27. Wing Ice Light (U-89 and After)
Only), Crossfeed Valve (LH Only), Fuel
Supply and Return Lines and Fuel System
Drain Tee (LH Only)
13. Electrical Wiring, Hydraulic Lines, Engine 28. Spar Inspection and Inverter Vent
Control Cables and ITT Balance Resistor
14. Battery (Optional Location) 29. Hydraulic Landing Gear Fill Can
15. Deice Lines, Electrical Lines, Firewall Fuel
Shutoff Valve, Fuel Purge Valve and
Engine Control Cables
Wing Center Section Access Openings (U-1 thru U-164, except U-50)
Figure 4 (Sheet 2 of 2)
Page 7
06-50-00 Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Figure 5 (Sheet 1 of 2)
Wing Center Section Access Openings (U-50, U-165 and After)
Page 8
Nov 1/10 06-50-00
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Page 9
06-50-00 Nov 1/10
MODEL 99 AIRLINER SERIES MAINTENANCE MANUAL
Figure 6
Wing Section Access Openings
Page 10
Nov 1/10 06-50-00