Professional Documents
Culture Documents
Loctite 271™: Technical Data Sheet
Loctite 271™: Technical Data Sheet
LOCTITE® 271™
March-2012
Stainless steel
Mil-S-46163A 0
LOCTITE® 271™ is tested to the lot requirements of Military 1min 5min 10min 30min 1h 3h 6h 24h
Cure Time
Specification Mil-S-46163A. Note: This is a regional approval.
Please contact your local Technical Service Center for more
information and clarification. Cure Speed vs. Temperature
The rate of cure will depend on the temperature. The graph
below shows the breakaway strength developed with time at
ASTM D5363 different temperatures on M10 steel nuts and bolts and tested
Each lot of adhesive produced in North America is tested to according to ISO 10964.
the general requirements defined in paragraphs 5.1.1 and
5.1.2 and to the Detail Requirements defined in section 5.2.
100
% of Full Strength on Steel
40 °C
UL Classification
Classified by Underwriters Laboratories Inc.® MH8007 - 75
22 °C
Fire hazard is small. No flash point in liquid state. Ignition
temperature 304°C. For use in devices handling gasoline,
50
petroleum oils, natural gas (pressure not over 300
PSIG), butane and propane not exceeding 2 in. pipe size.
4 °C
Note: This is a regional approval. Please contact your local 25
Technical Service Center for more information and clarification
0
1min 5min 10min 30min 1h 3h 6h 24h
Cure Time
TYPICAL PROPERTIES OF UNCURED MATERIAL
TDS LOCTITE® 271™, March-2012
Hot Strength
Tested at temperature
Cure Speed vs. Activator
Where cure speed is unacceptably long, or large gaps are 100
present, applying activator to the surface will improve cure
% Strength @ 22 °C
speed. The graph below shows the breakaway strength
75
developed with time on M10 zinc dichromate steel nuts and
bolts using Activator 7471™ and 7649™ and tested according
to ISO 10964.
50
100
% of Full Strength on Steel
25
Activator 7649™
75 0
0 100 120 150
Temperature, °C
50
1™ Heat Aging
747
or
at
tiv
25 tiv
ac
Ac
125
No
Reference 1.8