Professional Documents
Culture Documents
52SS Page 1
NOTE: Make sure the ignition is in the OFF mode and the doors are closed and unlocked.
NOTE: When programming the autolock feature, carry out the following steps within 30 seconds or the procedure needs to be repeated. If the
procedure needs to be repeated, wait 30 seconds between programming sessions.
5. NOTE: A chime sounds as acknowledgement that programming mode has been entered.
Turn the ignition to the RUN position. The module is now in programming mode.
6. Once in programming mode, the autolock or auto-unlock feature can be programmed independently of each other.
- To program the autolock feature, press the door lock control switch for greater than 2 seconds and relese. Each long press of the door
lock control switch toggles the state of the autolocking feature between enabled and disabled. A chime sounds when the feature is
enabled or disabled.
- To program the auto-unlock feature, press the door lock control switch for less than 1 second and release. Each short press of the door
lock control switch toggles the state of the auto-unlocking feature between enabled and disabled. A chime sounds when the feature is
enabled or disabled.