Maintenance
5.6.2.2 Replacement of Coolant
(whichever occurs firs)
Replace the coolant once every
tainer to contain th
drain valve on radiator, use a conta
2. Oy over, fill the ¢
2 Open the expansion water tank €
eran valve, slowly fill the coolant into expansion water tank until the |
m mark, and tighten up the expansion water tank cover
voling system: Start
air enters into coolant, please bleed the air. Air-bleeding method for ee
jon't ade tap water, river water
You must use the coolant of specified designation, and d
nd the components of cooling
‘or well water, otherwise the engine may get overheated, ai
‘system may get corroded.
‘Add the coolant in time. The too low level of coolant may lead to overheated engine and
corrosion.
In order to prevent air from entering into coolant, slowly fill the co
‘engine may get overheated and the cooling system may leak.
When any painted surface of vehicle is stained with coolant, use water to flush it away
immediately, so as to prevent the painted surface from getting corroded;
When replacing the coolant, use a container to contain the coolant and dispose of it in a
‘correct manner, so as to prevent the environmental pollution.
lant, otherwise the
‘The coolant is toxic and may not be orally taken. If the coolant is orally taken mistakenly,
‘get medical treatment immediately;
if the coolant is splashed into eyes unexpectedly, immediately use fresh water to flush
‘eyes for at least 15min, and get medical treatment as quickly as possible;
if the coolant is splashed onto skin, use alkalic water to thoroughly clean up the skin, and
then apply skin-care medicine; :
‘Tighten up the storage reservoir and store it in a safe place where is not
accessible by
children; "
The anti-freezing fluid is inflammable. When filling the anti-freezing fluid, keep away from
Eestsere. 0 a8 to prevent the occurrence of fire;
the engine is hot, itis
eee" Prohibited to open the cover of expansion water tank. Replace
ly after the engine has cooled down to appropriate temperatur
'50°C/122°F), as to prevent scalding! "|
A sany Safety, Operation & Maintenance - Oct 12, 2016
Ps56. inspection ereeton
* inspection on Tightening of Rubber Hose at Engine Intake Co”
pes and rubber hoses of
every day, and repair
ie. When replacing a hose
pressed air to clean it up.
of nuts, and tighten up
Ke on rubber hose at intake
Fig. 5-9
he intake pipeline is damaged or the nut is
loosened, the intake will
e
thus the operation of engine will be affected, es
5-32 Satlety, Operation & Maintenance . Oe, 12,
2016
S