Professional Documents
Culture Documents
Prosthodontics Report
Deflasking :
Is the removal of the mold from the flask and separates the denture
and the cast from the mold(divesting)
Steps of deflasking
1. Remove the flask from the clamp.
2. Remove the upper and lower lids.
3. Separate the 2 parts of the flask with attention using the plaster knife.
4. Liberate the denture with its model, then try to remove the model
carefully. If there is undercut, split the model into 2 or 3 parts to remove
them easily.
5. After gaining the denture, remove the excess of acrylic using the acrylic
bur.
After you start you have to make sure that the flask is cooled to room
temperature.
The prosedure of deflasking :
2. place the flask bottom side up in the flask ejector and tighten
thumbscrew until it contacts the bottom plate
3. place the pry bars through the slots in the side of flask ejector and
engage the slots in the flask between both halves of the flask
4. with pry bars engage pry down on them to separate bottom half of
flask and then pry up these movements readily separate the flask
from the stone enclosed denture
5. tap back of knife blade with plastic mallet to separate the stone cap
6. separating medium properly applied facilities separation of stone
cap exposing cusp tips of denture teeth
7. with a saw cut through the stone that encloses the denture opposite
the central incisor teeth
8. additional daw cuts are made at distobuccal corners of flasked
denture
Errors of deflasking:
Improper deflasking as used the hammer for knocking the flask may lead
to cracked or fracture of the denture base or the teeth