For € < 1, (8) canbe expanded using the binomial heo-
2
a
leh
Senin) ach in 0) exe oe
Semple acer
=
Te rng pms 0
soa fe ace
Gren crt ie
Rincon Geena ya
SLAP eter hes oe
EAROU SG Tennant
rao rd)
ei nd
Althoush he pplication is cavisaged te fr alway
sletfenton the autor have nloed the resistive ond
fase for compicenss. This const of sting ihe swtch
52 poston Inthe laboratory, tis cane the easter
{oconol and entre precy
For the switch 52 in postion E, the de cutpt ofthe
single-pass i
mG)
v
Treating VE ~ + 95s yariabl (12) i. isonder dit
feremial equacon in x Equatnp (3) w (12), the ned
sate rolution (or paula iterate) (12) is
ap
% (2)
Vi 4 (wba RelBY]!?
ne [Bette sin (2,0 + #)
os
Vi= RK ~ RE) (ay
“
ma cane to
The complementary Fonction hs salation ofthe form
3 cs)
‘This erm damps oa wo 2er afer few time constants,
0) = ae-2IME,
Infeasibie Operating Condiions
“Te restive load case hs neaibe operating regions
which ae no foun inthe blanco thre phase Hod eae
‘This i apparent when one solves for J nthe quaatic
equation of (14), which hs the formula
wile) al
Since 1, canot be complex number. the square soot
term in 19) cannot be negative Ths regiment ss
ished when
rome (20)
Inte laboratory he exnience ofthe infest region
Is readly cemonsite by rlucing the magnitde of V,
‘below the inequality of 20). The de link voltage col
laps.
Hn practice, ficiency requirements ensare that the
£R,/RE ratio is usually very sal, 90 thatthe infeasible
repo io academe interest oa
1, Dinter DC Ln Vouracs Fasoexce
In the research on the three-phase conole.curent
PWM recifer [10] 12}-[14]. thas been eatonee
for proper operate tore afe tive techs! problems
which ave to be salve,
1) The stiparalel diodes have to be aormlly back
‘biased so that he switching actions of he transistors can
‘oni the wavefomm ofthe as eurent. T= is done Dy
‘ensuring at the d ink voltage Fi always higher than
Sg pet of to vous a ht) 8 >
BY.
2) The dene voltae must be suclemly high so at
the modulator is enpableof tacking the arent wivefonn
sggenes tour nave tion ini) >
5) The ac cure! amplitude mast have fast response >
thatthe rete power input matches almost instante
seculy the dink power demands
Te has been shown th the three problems are solved
simply by making the dlink ito 'a regulated votage
eurce using proportional ncgative feedback, This con-
Ser of measuring the instantaneous de ink bolage Ve
Comparing withthe seternce Vy and using te fre
ontol the amplitude ofthe ac efarnce signal
“Applying the sre ide othe single-phase rete of
Fig T, the implementation of the direct voltage fedack
loop consis of sting the sitch SI to postion
Harmonic Feedback interference
‘Unforunstely. the harmonics inthe volge across the
ink capac C etfs ack so har the current ree
fence sigaliself i nt the desirable sinusoidal wave
form. To appre ths, conser the case fhm