Professional Documents
Culture Documents
How To Make Straight Cable
How To Make Straight Cable
To make a network cable using this UTP cable, there are some equipment that
we need to prepare, namely:
UTP cable
RJ-45 Connector
Crimping tools
RJ-45 LAN Tester
1. Peel the end of the cable about 2 cm, so that the small cable inside is
visible.
2. Separate the cable and straighten it. Then arrange and trim according to
color, namely White Orange, Orange, Green White, Blue, White Blue,
Green, White Chocolate, and Chocolate. After that cut the edges so that
they lie flat.
3. After the cable is set, take the RJ-45 Jack. As I said before this Jack
consists of 8 pins. Pin 1 of this jack is the pin on the far left if the pin is
facing you. The order to the right is jack 2, 3, and so on.
4. Insert the RJ-45 Jack that has been attached with the cable to the mouth
of the corresponding crimping pliers until the pin section of the RJ-45
Jack is inside the mouth of the pliers.
5. After that, pinch the jack with crimping pliers until all pins stick to the
cable.