BENCHMARK
GPmark™ DETAIL Xmark™ DETAIL
|--—— 4.156 +0008 ——-
(PIN CONNECTION LENGTH)
0.063
ey i 015 See Note 2 2.125 in
| See Note 2 Pit Free Zone
See Note 5
/ \ See BENCHMARK PRWARY WAKE-UP SHOULDER SECONDARY WAKE-UP. SHOULDER]
} (Sea) (PIN NOSE / MECHANICAL STOP)
I
Bevel Dia.
4.125 Oath 3.074 0081
Bevel Dia - IT (PIN NOSE. DIAMETER)
NOTES: |
1. Lead tolerance:
a. For 2 inches +0.006 inch
b. Recut threads if siretch exceeds 0.006 inch in 2 inches
2. Ether benchmark type is applicable but not both
a. GPmark: 0.125 is new condition, shall be 0.188 max. after refacing 0 Thread toper 0.750" per tt
b. Xmark: 0.063 is new condition. After refacing a visible step 3.5 Threads per inch
‘on the benchmark shall remain on the primary shoulder. See Note 4
Rethreading is required i there is no visible benchmark.
3, At Outside Diameter less than 4.188, Bevel Diameter is void Break Edge
and 1/32" x 45° becomes effective. 1/32" Max. x 45° Ref.
See Note 3
4, Surface finish requirement only applies during refacing operation.
5. Area of the connection where pitting is not permitted in the thread roots
# [Grant Prideco tiisics ar rox) _XIF™34 / uXT™34 Pin
RereRence | FELD INSPECTION DIMENSIONS
INFORMATION ONLY
2/2020
9/3/2020
Assigned to:
By:
06 | 828/2070
eww [a/za/zam0
Awe | 1L295 ror [61
ui
=
” HEH
Date: