The document provides instructions for a mechanics tutorial, including:
- Students must complete 3 problems independently by Friday at a provided link.
- The tutorial will be held on Saturdays from 9:00-11:00 WIB.
- File names should follow a specified format of KXX_NIM_Name.pdf.
The document provides instructions for a mechanics tutorial, including:
- Students must complete 3 problems independently by Friday at a provided link.
- The tutorial will be held on Saturdays from 9:00-11:00 WIB.
- File names should follow a specified format of KXX_NIM_Name.pdf.
The document provides instructions for a mechanics tutorial, including:
- Students must complete 3 problems independently by Friday at a provided link.
- The tutorial will be held on Saturdays from 9:00-11:00 WIB.
- File names should follow a specified format of KXX_NIM_Name.pdf.
- Everyone must collect the answer sheet in .pdf before Friday 24:00 WIB at http://bit.ly/Tutorial05MS2110 - The tutorial will be conducted on Saturdays, 09:00 – 11:00 WIB - Your filename should be in format: K0X_NIM_Name.pdf with X is your class number. For instance: K01_13119500_Ganesha
1. A steel loop ABCD of length 1.2 m and diameter 10 mm is
placed around a 24 mm diameter aluminum rod AC (see Figure). Cables BE and DF, each of 12 mm diameter, are used to apply the load Q. If the ultimate strength of the aluminum used for the rod is 260 MPa and the ultimate strength of the steel used for the loop and the cables is 480 MPa, determine the largest load Q which can be applied if an overall factor of safety of 3 is desired.
2. A rod with a T-shaped cross section is
subjected to a load distributed as can be seen in the figure. Determine the magnitude of normal stress that occurs due to the bending moment at point A.
3. For the beam and loading shown,
consider section n-n and determine a. The maximum shear stress in that section b. The shear stress at point a