Professional Documents
Culture Documents
The Resin Spelter Trainingsbuttons are composed of the main button and a ring which is located on
the top of the main button (Figure 1).
Figure 1 Figure 2
The geometry of the RS-Trainingsbuttons is 1 by 1 the geometry of the original Resin Spelter Button.
To applicate the RS-Trainingsbutton the button has to be used in the composed condition. The hole
of the ring on top has the same diameter than the core diameter of the thread in the original Resin
Spelter Button.
The brooming-, positioning- and pooring procedure of the RS-Trainingsbutton follows the warnings
and instructions of the original Resin Spelter Buttons.
After the hardening time of the resin it is possible to remove the ring and push back the
trainingsbutton to check the cone. It is important that the cone is completely full with the
WIRELOCK® resin without bubbles (Figure 2).
Status 08/2012