16/08 2010 15:49 0319982205
i.
PRODUCT SAFETY
INFORMATION
SHEET
seeon ae E:DTRD-PS.002
TREES 02.
P.T. NIPSEA PAINT AND CHEMICALS .
Jalan Anco} Barat VAS/CNo. 12
Jakarta 14430 , Indonesia
P.O. Box 4561/JAK
Emergency Phone —_: (021) 690 0546 ext, 130-133
Information Phone —: (021) 690 0546
P.T.NIPSEA PAINT GRESIK
Ba Kes -
Telefax No. : 021) 692 7778
E-mail, : nipsea @ indo.netid.
Date : Jakarta, Tune 30, 2009 (NPL SURABAYA))
Section L. Product Identification,
Product Name : BODELAC METAL PRIMER
Product Class : Alkyd Resin Based Primer
Product Code ‘BMPXXX
Customer Code. (419)
CAS No. Ingredients rage ACGIH TLV-TWA
61790-14-5 Lead Naphthenate 0.46 0.1 mg(Pb)/m?
61789-51-3 Cobalt Naphthenate 0.17 0.1. mg/m?
_ 67-56-1 Methyl Alcohol 0.21 200° ppm
Section IIL Physical/Chemical Data.
Boiling Range (°C) (64.8
Specific gravity (H20=1) : 1.4
Vapor Pressure (mm Hg,20°C) : na
Melting Point (°C) na
Vapor Density (Air=1) :>1
% Volatile/Volume 227
Evaporation Rate (Ether=1) : na
Solubility in Water : Insoluble
Appearance & odor Red Solid with repulsive pungent odor15/08 2010 18:43 0313902205 P.T.NIPSEA PAINT GRESTK
‘Section IV, Fire & Explosion Hazard Data,
FlashPoint (°C): 12.2 LEL (%):6 UEL (%) ! 36.5
Flammability Classification : FLAMMABLE “ = COMBUSTIBLE
Extinguishing Media :
Foam ¥ CO2 Vv DryChem =~ = Water Fog Other
Unusual Fire & Explosion Hazards :
‘Vapor is heavier than air and will travel considerable distance to a.
source of ignition and will flash back.
Special Fire Fighting Procedures :
Water maybe ineffective on fire.
Cool exposed containers with water.
Section V, Reactivity Data,
Stability : Unstable : Stable-¥
@_ —_Corcitions to avoid: High temperatures
Incompatibility _: Strong Oxidizers
Hazardous Decomposition Products : It emits acrid smoke and isritating fumes
Hazardous Polymerization : May Occur ‘Will Not Ocour ¥
‘Section VL Health Hazard Data,
‘Route(s) of Entry : Inhalation ¥ Skin ¥ Ingestion ¥
Effects of Overexposure :
Inhalation May cause headache, dizziness, and nausea.
Acute : Skin Contect- —_ Irritation
Eye Contact ~ Irritation
Chronic : Kidney and liver damage.
‘Emergency and First Aid Procedures :
Inhalation —_ Remove to fresh air.
Splash (eyes) : Flush immediately with large amount of
water for at least 15 minutes.
Splash (skin) ; Remove with soap and water.
Q
Remove contaminated clothings.
Ingestion Do not induce vomiting.
Get medical attention immediately.
‘Section VIL Spill or Leal Procedures,
Steps to be taken in case materials is released or spilled :
Spilled materials are to contained and removed with adsorbents and
sed.
dispo:
Waste Disposal Method :
Incineration or as according to applicable local regulations.15/08 2010 15:44 0
a
P.T.NIPSEA PAINT GRESIK #0218 P.003
een Pa SSNs UHI EURUE UNELEUtLe
Respiratory : In outdoor or open area, use approved mechanical filter respirator to
Protection remove solid airborne particles of overspray application.
In restricted ventilation areas, use approved chemical-mechanical
filters designed to remove a combination of particulates and gas
vapor.
In confined areas, use approved airline type respirator or hoods.
Ventilation :
Provide general dilution or local exhaust ventilation in volume and
pattern to keep TLV of most hazardous ingredients in Section
T.below
acceptable limit.LEL in Section IV. below stated limits and to remave
Gevommporiton prod dering welding of femmo muting on sirfate
ack with fis proton
Pockets of heavy, and/or flammable vapor must not be permitted to
Protective : form.
Gloves All application areas should be ventilated.
Bye Required for prolonged or repeated contact,
Protection
Other protect- : ‘Use safety eyewear with splash guards or side shields.
ive Equipments
Remove and wash contaminated clothing before use.
‘Section IX. Special Precauti :
Precautions tobe taken in: Do not sore above 45°C
handling and storing Keep containers tight and upright to prevent
leakage. 8
Keep container closed when not in use.
Other precautions Do not take internally: 4
‘Do not get into eyes.
Avoid skin contact,
This PRODUCT SAFETY INFORMATION SHEET has been approved by :
~2xw——