Professional Documents
Culture Documents
School of Mechanical Engineering Spr4054 - Cad Analysis Lab Manual
School of Mechanical Engineering Spr4054 - Cad Analysis Lab Manual
EXERCISE NO: 1
EXERCISE NAME: ANALYSIS OF CANTILEVER BEAM WITH POINT LOAD AT THE END
AIM: To analyse the deflection and stresses at each nodal points of a cantilever beam with point load at free
end using ANSYS software.
PROCEDURE:
Preprocessing:
1. Preferences-Structural-Ok
2. Define element type:Preprocessor-Element type-Add/Edit/Delete-Add-Beam, 2 Node 188-ok
3. Defining Material properties:Preprocessor-Material properties-Material models-Structural-Linear-
2
Elastic-Isotropic- E=2e5N/mm , Poisson ratio-0.3
4. Preprocessor-Section-Beam-Common sections [D=10mm].
5. Defining nodes:Preprocessor-Modeling-Create-Nodes-In active CS
Node 1 0 0 0
Node 2 100 0 0
6. Preprocessor-Modeling-Elements-Autonumbered-Thru nodes-Pick node 1 &2- click ok.
OUTPUT:
RESULT:
Thus the cantilever beam with point load at one end was analysed using ANSYS.