Professional Documents
Culture Documents
塔河油田 4区奥陶系缝洞型油藏特征及开发对策
李江龙 ,黄孝特 ,张丽萍
(中国石化石油勘探开发研究院 , 北京 100083)
摘要 :
塔河油田 4区储集体主要分布在奥陶系风化壳 , 呈不 规则网 状 。 储集 空间以溶 洞 、裂缝为 主 , 溶 洞高度 大多数 低于
2 m, 裂缝平均宽度大于 0. 1 mm 的层 段占总层段的 58%。 储 集体的平面分布与古 岩溶发育有关 , 古岩溶水道 的地震反射
特征呈串珠状强反射 , 深浅侧向测井异常具有幅度差 。 利 用蒙特卡 罗法计 算缝洞 型油藏 储量 , 一种方 法是利 用测井 解释
的结果 , 统计孔隙度 、有效厚度 、含油饱和度的概率分布 ;
另一种方法是假设孔隙度 、有效厚 度 、含 油饱和度为 精确值 , 储集
体面积符合某种概率 分布 , 求得每口井的储量分布 。 塔河 油田是块 状底水 油藏 , 油藏 的水体 主要由深 部发育 的古岩 溶水
道系统沟通底水 。 合理开发碳 酸盐岩缝洞型油藏应以缝洞单元为 基础 , 以循环 注水 、钻侧 钻井为主 要措施 , 宜 采用 “一井
一策 ”方针 。
关键词 :
缝洞单元 ;
古岩溶水道 ;
近地表古岩溶 ;
蒙特卡罗法 ;
开发对策
中图分类号 :TE112. 322 文献标识码 :
A
Ab stract:
Reservoirs in block 4 o f T ahe o ilfie ld a re m ainly distrib uted in O rdov ician weathe red crust and appea r
as irregu lar chicken- w ire pa tte rn. Solution cavities and fractures are the m a in ty pes of reservo ir space. The
height of m ost so lu tion caviteis is le ss than 2m, and th e fo rm ation inte rvals w ith ave rage fracture w id th of ove r
0. 1 mm account fo r 58% o f th e to ta.l A rea l distribu tio n o f reservo irs is re lated w ith the developm en t of fossil
kars.t Fossil karst channe ls appear as beaded strong seism ic re flec tion, and m agnitude differences exist be tw een
deep and shallow latero lo g anom alies. M onte Ca rlo m e th od is used to ca lculate reserve s o f fractured-
vuggy reser-
vo irs. One w ay is to achieve th e probability d istribu tion o f po rosity, ne t thickness and o il saturation based on in-
terpre tation of log da ta. Ano th er one is to ach ie ve rese rves distribution of each w e ll through assum ing tha t th e
valu es of po rosity , ne t thickness and o il sa tu ration are accurate and th e area o f rese rvoir body accords w ith cer-
tain probab ility d istribu tio n. T ahe oilfie ld is a m assive o il poo l w ith bo ttom w ater, being communicated w ith
deep fossil karst w ater channel system. Rational deve lopm en t of frac tu red-
vuggy carbonate reservo irs shou ld take
vug units as base s, cyclic w ate rflooding and late ra l drillin g as the principa l m easures, and “ one w e ll
fracture-
one schem e” as the guiding princip le.
cave unit;fo ssil karst channe l;near-surface fossil karst;
K ey word s:fractu re- M onte Ca rlo m ethod;development stra tegy
3 油藏水体
塔河油田是块状底水油藏 , 但对底水的认识以
及底水的分布尚未有定论 。依据古岩溶发育理论 ,
古岩溶水道储集带发育在古风化壳下深度不等的 图 3 “串珠 状 ”强反射特征
地带 , 受古水流的控制 , 由相对连通的主洞道和多 F ig.3 “ Beaded” strong reflection fea ture
第 5期 李江龙 , 等 :
塔河油田 4区奥陶系缝洞型油藏特征及开发对策
633
对于高含水井区 , 应采用 关井压锥措施 。 由 poo l in Tarim basin as an exam p le[ J] . Petro leum E xp loration &
D evelopm ent, 2000, 27(3):5 - 8
于底水通过发育在奥陶系较深部位的洞穴系统中
6 周兴熙. 再论网络状油气藏与轮南潜山勘探对策 [ J] . 石油勘
水体锥进 , 含水上升很快 , 控 制水体锥进难度大 , 探与开发 , 2002, 29(4):4 ~ 9
采用堵水措施效果可能不会很好 。因而对于深部 Zhou X ingx.i M y second discussion on netw ork-like oil and gas
洞穴系统发育的地区钻井不宜过 深 , 酸压强度不 pools and the exploration s trategy for Lunnan bu ried-
h ill pools
宜过大 , 要分析地层 中垂向裂缝不发育的层段作 [ J] . Petroleum E xp loration & D evelopm ent, 2002, 29(4):4 - 9
7 阎相宾. 塔河油田奥陶 系碳酸 盐岩储 层特征 [ J] . 石油 与天
为封隔层位 置 , 封死下 部水体 , 以达 到控水 的目
然气地质 , 2002, 23(3):262 ~ 266
的。 Y an X iangb in. C haracteristics of O rdovician carbonate rock reser-
对于低 效井和 无产能 井应依 据地 震反 演特 voir in Tahe oilfield [ J] . O i l & G as G eo logy, 2002, 23(3):
性 、储层预测 结果 , 并结合周围油井 动态特征 , 向 262 - 266
可能发育的缝洞单元钻侧钻井或 侧钻水平井 , 以 8 张希明 , 杨坚 , 杨秋来 , 等. 塔河缝洞型碳酸盐岩油 藏描述及
储量评估技术 [ J] . 石油学报 , 2004, 25(1):13 ~ 19
提高平面上的储量动用程度 。
Zh ang X im ing, Y ang Jian, Y ang Q iu lai, e.t a.l R eservoir des-
至于合理的采油速度和单井的采油 强度 , 应
crip tion and reserves estim ation techn ique for fracture cave type
依据单井钻遇的缝洞单元特征来确定 。 根据目前 carbonate reservoir in Tahe O i lf ield [ J]. A cta Petrolei S inica,
生产实际 , 采用 “一井一策 ”可能是最好的选择 。 2004, 25(1):13 - 19
9 柳建华. FM I成像测井技术在塔河 碳酸盐岩油田的 应用 [ J] .
参 考 文 献
新疆石油地质 , 2001, 22(6):487 ~ 490
Liu Jianhua. The effectiveness for app lying FM I w ell logging in
1 张希明. 新疆塔河油田下奥陶统碳酸盐 岩缝洞型油气藏 特征
[ J] . 石油勘探与开发 , 2001, 28(5):17 ~ 22 carbonate reservoir of Tahe oilfield[ J] . X in jiang Petroleum G eolo-
Zhang X im ing. The characteris tics of Low er O rdovician fissu re vug gy, 2001, 22(6):487 - 490
carbonate oil and gas pools in Tahe oil field, X in jiang[ J] . Petro- 10 景 建恩 , 梅忠武 , 李舟波. 塔河油田 碳酸盐岩缝洞型 储层的
测 井识别 与评价 方法研 究 [ J]. 地 球物理 学进 展, 2003, 18
leum Exploration & D evelopm en t, 2001, 28(5):17 - 22
(2):336 ~ 342
2 杨明德. 喀斯特流 域水文地 貌系统 [ M ] . 北京 :
地 质出版 社 ,
1998. 47 ~ 200 Jing Jian′en, M ei Zh ongw u, Li Zhoubo. Investigation on w ell log-
Y ang M ingde. Hydrogeomorphological system in karst d rainage a- ging m ethod s for ident ifying and evaluating fractu re-vug type car-
rea[M ]. B eijing:G eological Pub lish ing H ou se, 1998. 47 - 200 bonate reservoirs in Tahe oi l f ield [ J] . Progress in G eophysics,
2003, 18(2):336 - 342
3 黄孝特. 碳酸盐岩裂缝 -溶洞型油气藏开发技术探讨 [ J] . 石
11 李 翎 , 魏 斌 , 贺 铎华. 塔河油田奥陶 系碳酸盐岩储层 的测井
油实验地质 , 2002, 24(5):446 ~ 451
Huang X iaote. A n app roach on the development techno logies of 解释 [ J] . 石油与天然气地质 , 2002, 23(1):49 ~ 55
f issure k arst cave type hyd rocarbon poo ls in carbonate rock [ J] . Li Ling, W ei B in, H e D uohua. Log in terp retation of O rdovician
Petroleum G eology & Experiment, 2002, 24(5):446 - 451 carbonate reservoirs in Tahe oilfield [ J] . O i l & G as G eology,
2002, 23(1):49 - 55
4 肖玉茹 , 何 峰煜 , 孙 义 梅. 古 洞穴 型 碳酸 盐 岩储 层特 征 研
12 李昌全. 赤水地区碳酸盐缝、洞型气藏地质 模型讨论 [ J] . 贵
究 ——— 以塔河油田奥陶系古洞穴 为例 [ J] . 石油与 天然气 地
质 , 2003, 24(1):75 ~ 82 州地质 , 2000, 17(2):71 ~ 79
X iao Y uru, H e Fengyu, Sun Y ime.i R eservoir characterist ics of Li Changquan. A d iscussion on the geological m odel of carbonate
paleocave carbonates:a case s tudy of O rdovician paleocave in Tahe seam-cavern typ e gas poo l in Ch ishu i region[ J]. G u izhou G eolo-
oilfield, Tarim basin[ J]. O il & G as G eology, 2003, 24(1): gy, 2000, 17(2):71 - 79
13 任 玉林 , 李江龙 , 黄孝特. 塔河油田 碳酸盐岩油藏开 发技术
75 - 82
5 周兴熙. 初论碳酸盐岩网络状油 气藏 ——— 以塔里木盆地 轮南 政策研究 [ J] . 油气地质与采收率 , 2004, 11(5):57 ~ 59
奥陶系潜山油气藏为例 [ J]. 石油勘探与开发 , 2000, 27(3): R en Yu lin, L i Jianglong, Hu ang X iao te. S tudy on deve lopm en tal
Zhou X ingx.i A prim ary discussion on the network-like oil and gas G eology and R ecovery E fficiency, 2004, 11(5):57 - 59