om
2
3
a4
a
Tailplane
1/16" sheet balsa
LINNET
18swg
spring wire.Senior Series
FROG:
+ 4 +
WING.
This is built over the plan, so it is advisable to pin a sheet of grease:
proof or tracing paper over it to prevent the cement sticking to f
Pin down the leading and trailing edges over the drawing, then
remove the ribs W1—W4 from che princed sheet (W3 is on the fuselage
panel) and cement these into place. together with the tp pieces. ‘Then
ement the spar in place and you should have ewo wing-halves as shawn
in fig. 3. When both sides are set, lift them from the plan, and assemble
them with the tips raised as in fig. 4. Build up the cenere section wich
short pieces of the same materials 25 the wing, and well cement round
the spar joine. See fig. 5. Then cover che centre-section with note paper
cr use a double layer of tissue when covering
‘When it is quite set. remove the wing fram the plan, and shape the
trailing edge as shown in fig. 3, but leave the centre part square to ft the
fuselage, Round off the leading edge and vips, emicath down the ‘vhole
wing and apply a coat of dope before covering.
COVERING.
Fhe fuselage and wing require covering with the tissue paper
tupplied. Stare with the fuselage and cover Sach tide reparseey Cot
FIG. 3
BUILD WING IN TWO SECTIONS
‘OVER PLAN.
a
Eerips of tissue wide enough t9 ail
paste for sticking it ro the framewor
fuselage, stretch a strip of the tissue o
Trim off any excess, and smooth dor
other sides, leaving 3 gap on the bot
When the paste is dry, lightly sp
it, and when it is thoroughly dry aga
also help to tighten she paper. Appl;
tailplane and ‘fin,
Cover the wing wich 4 pieces,
seneretecon, Sirk with the bose
the outer edges only. There is no
When covering the top surface start
lap the outer pieces onto it and rem
‘end to end, to help preserve the airf
Dope each halfewing separately,
when ics haifdry, to prevent it warpi
FIG. 4
RAISE WING-TIPS AS
OBTAIN DIHEDRA!
ASSEMBLING THE TW
+ 2
ayer e yar «
WING
(Full size)
SPAR ft” x am"
RAILING EDGE
aye yejoc “LINNET”
+ 4
srough to allow a small overlap, Use dope or
the framework. Apply some co ene side of the
of the tissue aver it and smooth aut any wrinkles
nd smocth down the edges. Repeat this for the
tap on the bottom surface below the rear motor