Базовая настройка

Smxa
enable

conf t

line console idle-timeout 255

vlan 10

exit

vlan 20

ip address 192.168.200.50 255.255.252.0

exit

add-rack rackno 1 racktype C320Rack

add-shelf rackno 1 shelfno 1 shelftype C320_SHELF

add-subcard rackno 1 shelfno 1 slotno 4 subcardno 1 UCDC/3 (ucdc/1 smxa1)

add-card rackno 1 shelfno 1 slotno 1 GTGO

int xgei_1/4/2

no shutdown

switchport mode trunk

switchport vlan 10 tag

exit

show gpon onu uncfg

OnuIndex Sn State

---------------------------------------------------------------------

gpon-onu_1/1/1:1 ZTEGC41A7966 unknown

gpon

profile tcont UP-1000MB type 4 maximum 1024000

profile traffic DOWN-1000MB sir 10240 pir 1024000

exit
interface gpon-olt_1/1/1

onu 1 type ZTE-F628 sn ZTEGC41A7966

exit

interface gpon-onu_1/1/1:1

sn-bind enable sn

tcont 1 name T-INET profile UP-1000MB

gemport 1 name G-INET unicast tcont 1 dir both

gemport 1 traffic-limit downstream DOWN-1000MB

switchport mode trunk vport 1

switchport vlan 10 tag vport 1

exit

pon-onu-mng gpon-onu_1/1/1:1

gemport 1 flow 1

vlan port eth_0/1 mode tag vlan 10

exit

QNQ

Глобально активируем функцию

vlan-smart-qinq enable
cvlan – влан клиентского сервиса , на ONU
svlan - сервис влан (внешняя метка )
vlan-smart-qinq ingress-port gpon-olt_0/1/1 cvlan 1024 to 1500 svlan 777

режим работы пон порта в vlan-smart-qinq

interface gpon-olt_1/1/1
  uncfg-onu-aging-time 30
  dba period-mode low-delay
  discover-period new-onu 2 miss-onu 0

  vlan-smart-qinq enable   
В данном режиме работы настройка влана на uni портах не нужна !

interface gpon-onu_0/1/1:1  
  sn-bind enable sn
  tcont 1 name inet profile UP-500MB
  gemport 1 name ginet  unicast tcont 1 dir both
  gemport 1 traffic-limit downstream 100M 
  switchport mode trunk vport 1
 На uplink интерфейсе должен быть разрешен svlan
interface gei_1/4/1
  hybrid-attribute fiber
  negotiation auto
  flowcontrol disable
  description uplink
  port-protect disable
  uplink-isolate disable
  switchport mode trunk
  switchport vlan ,777  tag