Professional Documents
Culture Documents
Information including Drawings, Schematics, Links and Code (Software) Supplied or Referenced in this Document is supplied
by MPJA inc. as a service to our customers and accuracy or usefulness is not guaranteed nor is it an Endorsement of any
particular part, supplier or manufacturer. Use of information and suitability for any application is at users own discretion and
user assumes all risk.
Information Subject to Change Without Notice
All rights are retained by the respective Owners/Author(s)
Instructions
6: Adjusting Calibration (CA): (Error between measured temperature and standard temperature)
6A: Thermostat #1 (LEFT Side)
Press SET Button 1 time to select the Left thermostat.
Press & Hold the “SET” Button
“HC” will Display
Use the s and t to Scroll through through modes until Display shows “CA”.
Press the “SET” Button
Preset value will Display
Use the s and t to set the degrees of + or- Offset.
After selection Wait 5sec. and selection will be stored.
6B: Thermostat #2 (RIGHT Side)
Press SET Button 2 times to select the Right thermostat.
Follow the same procedure as with Thermostat #1