Professional Documents
Culture Documents
jueves, 28 de marzo de 2019 18:19:53 Page 2 © 2011 Mitchell Repair Information Company, LLC.
2007 Ford Freestar
2007 TRANSMISSIONS Automatic Transaxle/Transmission - Freestar & Monterey
jueves, 28 de marzo de 2019 18:19:53 Page 3 © 2011 Mitchell Repair Information Company, LLC.
2007 Ford Freestar
2007 TRANSMISSIONS Automatic Transaxle/Transmission - Freestar & Monterey
message.
P0755, SSB SSB solenoid Solenoid 2 circuit Incorrect gear Go to Pinpoint Test
P0758b circuit failure. fails to provide selection A.
voltage drop depending on
across solenoid. condition mode
Circuit open or and manual lever
shorted or PCM position. See
drive failure Solenoid
during on-board Operation chart.
diagnostics. Will display
Check
Transmission
message.
P1715 SSB SSB failure. Mechanical Incorrect gear Go to Pinpoint Test
failure of the selection H.
solenoid detected. depending on
condition, mode
and manual lever
position. See
Solenoid
Operation chart.
P1716 SSC SSC failure. Mechanical Incorrect gear Go to Pinpoint Test
failure of the selection H.
solenoid detected. depending on
condition, mode
and manual lever
position. See
Solenoid
Operation chart.
P0760, SSC SSC solenoid Solenoid 3 circuit Incorrect gear Go to Pinpoint Test
P0763b circuit failure. fails to provide selection A.
voltage drop depending on
across solenoid. condition mode
Circuit open or and manual lever
shorted or PCM position. See
drive circuit Solenoid
failure during on- Operation chart.
board diagnostic. Will display
Check
Transmission
message.
P0731 SSA, SSB 1st gear Incorrect gear Incorrect gear Go to Pinpoint Test
or internal failure. ratio while selection A.
parts commanding 1st depending on
gear. condition mode
and manual lever
position: see
Solenoid
Operation chart.
Shift errors may
also be due to
jueves, 28 de marzo de 2019 18:19:53 Page 4 © 2011 Mitchell Repair Information Company, LLC.
2007 Ford Freestar
2007 TRANSMISSIONS Automatic Transaxle/Transmission - Freestar & Monterey
other internal
transaxle
concerns (such as
stuck valves,
damaged friction
material) (TCIL
flashing,
California only).
P0732 SSA, SSB 2nd gear Incorrect gear Incorrect gear Go to Pinpoint Test
or internal failure. ratio while selection A.
parts commanding 2nd depending on
gear. condition mode
and manual lever
position: see
Solenoid
Operation chart.
Shift errors may
also be due to
other internal
transaxle
concerns (such as
stuck valves,
damaged friction
material) (TCIL
flashing,
California only).
P0733 SSA, SSC 3rd gear Incorrect gear Incorrect gear Go to Pinpoint Test
or internal failure. ratio while selection A.
parts commanding 3rd depending on
gear. condition mode
and manual lever
position: see
Solenoid
Operation chart.
Shift errors may
also be due to
other internal
transaxle
concerns (such as
stuck valves,
damaged friction
material) (TCIL
flashing,
California only).
P0734 SSA, SSC, 4th gear Incorrect gear Incorrect gear Go to Pinpoint Test
or internal failure. ratio while selection A.
parts commanding 4th depending on
gear. condition mode
and manual lever
position: see
Solenoid
jueves, 28 de marzo de 2019 18:19:53 Page 5 © 2011 Mitchell Repair Information Company, LLC.
2007 Ford Freestar
2007 TRANSMISSIONS Automatic Transaxle/Transmission - Freestar & Monterey
Operation chart.
Shift errors may
also be due to
other internal
transaxle
concerns (such as,
stuck valves,
damaged friction
material) (TCIL
flashing,
California only).
P1000 OBD II OBD II Test On-board tests - Refer to the
system not complete. have not Introduction -
completed. Gasoline Engines
article.
P1460 A/C A/C clutch A/C or Defrost Failed ON - EPC Refer to the
cycling ON condition pressure slightly Introduction -
pressure switch may result from low with A/C Gasoline Engines
error. A/C clutch being OFF. article.
ON during on- Failed OFF - EPC
board diagnostics. pressure slightly
low with A/C
ON.
P1703 BPP Brake not Brake not cycled Failed ON or not Refer to the
actuated during during KOER. connected - Introduction -
on-board Brake ON/OFF torque converter Gasoline Engines
diagnostics. circuit failure. clutch will not article.
BPP switch engage at less
circuit failed. than 1/3 throttle.
Failed OFF -
torque converter
clutch will not
disengage when
brake is applied.
P0705 Digital TR Digital TR Digital TR sensor Increase in EPC Go to Pinpoint Test
sensor sensor circuit circuits, pressure (harsh D.
failure. indicating an shifts). Defaults
invalid pattern in to Overdrive
TR_D. Condition (Circle D) or D
caused by a short for all gear
to ground or an positions. In
open in TR4, Overdrive (Circle
TR3A, TR2 D) position
and/or TR1 transmission is
circuits. This stuck in D or
DTC cannot be manual 2.
set by an
incorrectly
adjusted digital
TR sensor.
P0708 Digital TR Digital TR Digital TR sensor Increase in EPC Go to Pinpoint Test
jueves, 28 de marzo de 2019 18:19:53 Page 6 © 2011 Mitchell Repair Information Company, LLC.
2007 Ford Freestar
2007 TRANSMISSIONS Automatic Transaxle/Transmission - Freestar & Monterey
jueves, 28 de marzo de 2019 18:19:53 Page 7 © 2011 Mitchell Repair Information Company, LLC.
2007 Ford Freestar
2007 TRANSMISSIONS Automatic Transaxle/Transmission - Freestar & Monterey
never engages
(Open circuit)
(MIL on).
P0960 PCS PCS open Voltage through Open Circuit - Go to Pinpoint Test
circuit failure. EPC solenoid is Causes maximum E.
checked and EPC pressure,
compared to a harsh
voltage through engagements and
solenoid after a shifts (TCIL
time delay. An flashing).
error will be
noted if tolerance
is exceeded.
KOEO and
continuous on-
board diagnostics.
P0962 PCS PCS circuit Voltage through The PCM Go to Pinpoint Test
shorted to EPC solenoid is removes VPWR E.
ground. checked and to the PCS which
compared to a opens the circuit
voltage through and provides
solenoid after a maximum
time delay. An pressure.
error will be
noted if tolerance
is exceeded.
KOEO and
continuous on-
board diagnostic.
P0963 PCS PCS circuit Voltage through The PCM Go to Pinpoint Test
shorted to EPC solenoid is removes VPWR E.
VPWR. checked and to the PCS which
compared to a opens the circuit
voltage through and provides
solenoid after a maximum
time delay. An pressure.
error will be
noted if tolerance
is exceeded.
KOEO and
continuous on-
board diagnostic.
P1117 ECT ECT sensor or PCM has detected Incorrect EPC Refer to the
circuit signal an intermittent pressure, either Introduction -
intermittent. signal. high or low which Gasoline Engines
will result in article.
harsh or soft shift.
P1700 LOW OWC Transaxle Failure of the No 1st, 2nd Refer to Diagnosis
mechanical LOW OWC. and/or reverse By Symptom.
failure. NOTE: P1700 gears, code
may be set by a P0731, P0732
jueves, 28 de marzo de 2019 18:19:53 Page 8 © 2011 Mitchell Repair Information Company, LLC.
2007 Ford Freestar
2007 TRANSMISSIONS Automatic Transaxle/Transmission - Freestar & Monterey
The Rotunda Transmission Tester is used to diagnose electronically controlled transaxles and is used in
conjunction with the pinpoint tests. The tests should be carried out in order. Installing the Rotunda
Transmission Tester allows separation of the vehicle electronics from transmission electronics. For
additional information, refer to the Rotunda Transmission Tester manual for these tests.
jueves, 28 de marzo de 2019 18:19:53 Page 9 © 2011 Mitchell Repair Information Company, LLC.