Professional Documents
Culture Documents
II. Light transmission of a high order is 12. The telescope is waterproofed; that is,
obtained through the fact that all air-glass it is tested under compressed air and sealed
surfaces are bloomed, including the exterior in manufacture against the admission of the
surfaces of the object glass and the eyepiece. outer atmosphere, This prevents the conden-
RESTRICTED
Fig. 3. Packing of rifle and sight
Identif!cati on
14. The main nomenclature of
the telescope is engraved on the
upper side of the telescope tube.
Below this, appear the manu-
facturing data, thus:- Fig. 4. Attachment points for sight
RESTRICTED
This leof issued with A.t. No. 32, September, 1952 A.P.I64IP, Vol. I, Sect. I, Chop. 13
16. To enable the clamping pieces to remain lens surfaces are bloomed. If, for any reason
paired with their cradle portions of the the blooming is removed, the letter B is
mounting, each is stamped with its identity, erased.
and the same marking appears-on the mating
cradle piece, on the right-hand side. This 18. Also on the sight tube is the letter W
marking usually consists of a three-digit in red oil paint, t in. high. This is put on the
number. sight at the successfulconclusion of its water-
proofing test. If any sight fails to pass this
17. The letter B appears on the sight tube test, the letter W does not appear. If the
i in. high, to denote that the
in blue oil paint, sight is satisfactory in all other respects, it
RESTRICTED
Fig. 6. Components of sight
may be issued for use in temperate climates. numbered intervals of 100 yards and un-
Waterproofed sights may be used in tropical numbered intermediate markings of 50 yards.
climates without the risk of condensation on
the internal air-glass surfaces of the lenses. 20. The deflection drum, which is on the
left-hand side of the graticule housing, is
Range and deflection adjustments graduated to left and right of zero up to 16,
19. The range setting required is obtained in numbered intervals of 4 with un-numbered
by rotation of the range drum situated on the intermediate markings representing 2. These
_.
upper side of the graticule housing. The drum
is graduated from zero to 1,000 yards with
/ -.......___
figures denote minutes of angle of deflection,
left or right.
,/
/
"" ,
"--- -
__[' ARE IN INCHES
. '
/ .
A. CROSSWIRE DETAIL B. PICTURE PRESENTEDTO FIRER
RESTRICTED
....
This leaf issued with A.L. No. 32, September, 1952 AP.14bl P, Vol. I, Sect. I, Chop. 13
I·
1·45
I
• I
m
.;.
0,,"
0
rJ-~
GO
2 -- .
F.
_ _. .--' _.
.;.
.._Q. ~- -
~
X 0
..-!--
:I:.,J
Oa-
~ -
.n
~
\ Oa-
I I Oa-
":'0
DIMENSIONS ARE IN INCHES
- I
11·013
\
RESTRICTED
P21179 50224/G6087 1O/~2 4000 C & P Gp, 1