Professional Documents
Culture Documents
Introduction
This Hardware Design Project will access each competitor’s skill and capacity.
1. Competitor can design a circuit of product based on the given drawing and
instruction.
2. Competitor can design Printed Circuit Board using Altium Designer CAD tool (Altium
designer 16/17/18).
3. Competitor can complete his product with enough functions.
d) Build and Test Hardware design project (Time limit: 2.0 Hr)
Assemble PCB, and check its operation.
Completing the project, submit all the product and documents.
This circuit is the control speed motor simulation. This circuit has 4 speed control and Motor
is simulated using led bit 8. Speed of rotating led, according to the speed shown on display
seven segment. See table below for description of speed and condition of display seven
segment:
Seven
Speed Led Move
Segmen
0 Stop
1 4,25 Hz
2 8,5 Hz
3 34 Hz
Block diagram
Size ± 0,2 mm
IN OUT
LABEL CLOCK CLK_1 CLK_2 CLK_3
VALUE 68 Hz 34 Hz 8,5 Hz 4,25 Hz
OUT
LABEL EN_3 EN_2 EN_1 CLOCK_SEL
0 0 1 CLOCK_SEL = CLK_1
VALUE 0 1 0 CLOCK_SEL = CLK_2
1 0 0 CLOCK_SEL = CLK_3
IN OUT
CLOCK_SEL RESET A2 A1 A0
↑ 1 0 0 0
↑ 1 0 0 1
↑ 1 0 1 0
↑ 1 0 1 1
↑ 1 1 0 0
↑ 1 1 0 1
↑ 1 1 1 0
↑ 1 1 1 1
X 0 0 0 0
↑ = LOW-to-HIGH CP transition
0= LOW Level, 1 = HIGH Level, X = don’t care
IN OUT
A2 A1 A0 LED 8 LED 7 LED 6 LED 5 LED 4 LED 3 LED 2 LED 1
0 0 0 OFF OFF OFF OFF OFF OFF OFF ON
0 0 1 OFF OFF OFF OFF OFF OFF ON OFF
0 1 0 OFF OFF OFF OFF OFF ON OFF OFF
0 1 1 OFF OFF OFF OFF ON OFF OFF OFF
1 0 0 OFF OFF OFF ON OFF OFF OFF OFF
1 0 1 OFF OFF ON OFF OFF OFF OFF OFF
1 1 0 OFF ON OFF OFF OFF OFF OFF OFF
1 1 1 ON OFF OFF OFF OFF OFF OFF OFF
IN OUT
UP DOWN RESET SEVEN SEGMENT
↑ 1 1 COUNTER UP If value display > 3, then value display = 0
1 ↑ 1 COUNTER DOWN If value display <= 0, then value display = 0
↑ 1 0 RESET value display = 0
1 ↑ 0 RESET value display = 0