(G6KV SUBSTATION MECHANICAL AND ELECTRICAL REQUIREMENTS
35 Cranes and Hoists
-\ Electric operated travelling crane shall be provided to respective switchrooms:
as follows:
Capacity Hoisting Transverse and Geearance height |
Switelvoom| of erane Speed Long Travel Speed {tom finshed
(Tonne) | Fast ‘Siow Fast Slow Aorlevel to
underside of
ie) | evi) | (i i)
Ceti | tose) | (iy | triode tn
5 5) 1520 3 6
3.5.2 Lifting hoists shall be provided where equipment are located at upper storeys
of a multi-storey substation building. The building can be so designed that
only one hoist is required for various equipment. In such a case, lifting hoist
of the greatest capacity and clearance height required shall be used.
3.5.3 The following table shows the type and capacity of lifting hoists required for
respective switchgear / transformer equipment:
Hoisting Goss ‘Clearance
Speed Travel bight from
Type ot Equipment | Capacty Spoed finished Hor
ot Host levelto
(tonne [Fast | Slow | Fast | Slow | underside of
boiet hook
(oii | eniny | (vin)
a (m
54 SIG 10 v5 | 20 5 6
‘KV 1G
(for upgracing of 6 eo | 115 | 20 5 4
seston)
22K, 68KV SIG 5 eo | 5 | 2 5 as
VATE 10 eo | m5 | 2 5 4
Relay room equipment 3 ew | ms | 2 5 30
3.5.4 The minimum clearance height of crane & hoist shall be at least 1000mm
{rom the finished floor level to the underside of crane / hoist hook when the
wire is fully extended.
3.5.5 The remote control "pendent” of crane & hoist shall also include the
"EMERGENCY STOP" and "RESET" buttons. The control “pendent” shall
hang-down to about one metre above floor level. Suitable wall-mounted
holder for the control "pendent" shall also be provided.
Eaton 62 0