You are on page 1of 78

Ailyn G.

Atienza
 Static GNSS surveys deliver the highest-accuracy positions
available in a system, which occupies a point for longer
periods of time
 Used for establishing controls
Receiver Type Serial No. Controller Antenna Type

SPS 985 5506F93019 Mobile phone/ SPS985 Internal

Laptop via WiFi

SPS 985 5506F93009 Mobile phone/ SPS985 Internal

Laptop via WiFi

SPS 855 5315K42734 Receiver/Lapto Zephyr Geodetic 2

p via LAN
Receiver Type Serial No. Controller

Sokkia GRX2 1169-10234 Tablet/Laptop

Sokkia GRX2 1169-10232 Tablet/Laptop


 GPS
 SBAS
 GLONASS
 QZSS
 Galileo
 BeiDou
 GPS
 SBAS
 GLONASS
 QZSS
 GPS
 SBAS
 GLONASS
 QZSS
 Galileo
 Stable location
 No overhead obstruction up to 10 degrees
 Determine ideal date and time of survey
 Slope height or vertical height
 Measured to:
 Bottom of Notch  Bottom of Antenna Mount  Phase Center
 Slope height or vertical height
 Measured to:
 Bottom of Antenna Mount
 Lever of Extension (slant height)
 Bottom of Quick release
 Local time vs GNSS time
 Scheduled and actual survey time
 Power on Trimble receiver
 Check if WiFi is on. If not, reset receiver
 Connect your mobile phone or laptop via WiFi
Password: abcdeabcde
 Open your browser and go to http://192.168.142.1/
 Set your parameters
 Enable static observation
 Power on Trimble receiver
 Connect receiver to PC via LAN
 Open your browser and go to http://169.254.1.0/
 Set your parameters
 Enable static observation
90
 Power on Sokkia receiver
 Open MAGNET Field software on tablet/PC
 Connect receiver via Bluetooth
 Verify if data was collected with correct time and date
 Back up data immediately
 Record slant height again
*RINEX data is desired
T02 files can be
downloaded
 Converts T02 files to RINEX
 Can be downloaded from the Trimble website
 The latest version of the Trimble Configuration
Utility must be installed prior to operation of
this utility
 File > Open  File > Convert Files

 Output RINEX files automatically saved in the same folder


 TPS files are automatically saved in the controller memory
or receiver SD Card
 Documents > MAGNET Field PC > Raw Data
 Converter downloadable at TOPCON website (need to sign up)
GNSS Solutions
 Signal to Noise Ratio
 Satellite Elevation
 Carrier Phase
 Press F5 key

 Green: QA test was successful for these vectors


 Red: QA test failed for these vectors.
 Error ellipse: horizontal uncertainties
 Vertical error bars: vertical uncertainties
 Used to detect problems in the observations and control
coordinates.
 You may have to iterate several times, using a number of
different tools to check for blunders
 Final product must be a blunder free adjustment
 Use only one control point
 Network Connectivity Test
 Variance of Unit Weight/ Standard Error of Unit Weight
 Chi-Square Test
 Observation Residuals
 Tau Test
 Loop Closure Analysis
 Repeat Vector Analysis
 Control Tie Analysis
 When you are confident that no blunders remain
 Hold all control points fixed and readjust to obtain final site
position and accuracies
 Define all your control points
 Adjust Network again (F7)
 Project > Land Survey Report
 GNSS Solutions Reference Manual
 Static GNSS Lecture by Vince Cronin (Baylor University) & Shelley Olds (UNAVCO)
 Static GPS/GNSS Survey Methods Manual by Ian Lauer (Idaho State University)

You might also like