Professional Documents
Culture Documents
1. Check HW-Requirements
CPU Type __________________________
CPU Rate ______MHz
RAM Extension ______MByte
SCSI-Host Adapter 1 __________________________
SCSI-Host Adapter 2 __________________________
Hard Disk 1 Capacity ______GByte SCSI-Address ____ Termination Yes No
Hard Disk 2 Capacity ______GByte SCSI-Address ____ Termination Yes No
Hard Disk 3 Capacity ______GByte SCSI-Address ____ Termination Yes No
Tape Capacity ______GByte SCSI-Address ____ Termination Yes No
CD-ROM Drive __________________________ SCSI-Address ____ Termination Yes No
LAN Adapter Type __________________________
disabled Power Management in BIOS Yes No (active Power Management will slow down the Processor)
Cache BIOS is set to "Write Back" Yes No ("Write Through" results loss of 50 % Performance)
LAN Adapter Driver installed Yes No (For Stand Alone PC and Laptop without installed LAN-Card must be
installed Loopback Adapter. After this installation a reinstallation
of Service Pack is recommended.)
TCP/IP Service installed Yes No
TCP/IP Address . . .
Subnet Mask . . .
Hostess i Card
RAMs equipped Yes No `|
RAMs and Controller type is 60 nsec Yes No |
Jumper on Board checked Yes No |
Dipswitches on Board checked Yes No |> (according documentation ACI_TAC3_Info [ACI-Service ITMN])
Location of Oscillators checked Yes No |
Jumper in Box checked Yes No |
EISA/ISA-Configuration Yes No ,| <= (only if the QD2-Card does not work after installation)
Additional Paths are possible but they should located after the Versant entries.
During Startup of WIN NT never press Space Bar for former Hardware Settings.
524154780.doc Page 5 von 8 30. Apr. 02
Check List for Installation of PC and Management System ACI
9. Troubleshooting NT (Networking):
%winroot%\system32\drivers\etc\HOSTS
- if necessary reduce of Alias Names (Default localhost, + if necessary Application entries)
e.g.:
127.0.0.1 localhost
218.1.31.87 nwi_server3 # Added by AccessIntegrator Installation
132.29.1.33 timehost
%winroot%\system32\drivers\etc\LMHOSTS
- make NT-PC’s public to other LAN-Segments
(all Primary and Backup Domain-Controller with #DOM:<Domain>)
e.g.:
218.1.31.69 NWI_CLIENT1 #PRE
218.1.31.68 NWI_CLIENT2 #PRE #DOM:NWI_DOMAIN2
218.1.31.70 NWI_REMOTE1 #PRE #DOM:NWI_DOMAIN2
218.1.31.67 NWI_SERVER1 #PRE
218.1.31.83 NWI_SERVER2 #PRE #DOM:NWI_DOMAIN2
The continuos and controlled Data Rate as a function of time gives answers about the quality of the LAN/WAN-
Connection.
30. Apr. 02
Check List for Installation of PC and Management System ACI
On Workstations:
Start -> Settings -> Control Panel -> Network -> Identification
- Change Domain to Workstation
On Domain-Controller:
Start -> Programs -> Administrative Tools -> Server Manager
- Remove Workstations and Standalone-Server from Domain
(15 min update time but it is not necessary to wait for the notification)
- select Backup Domain-Controller and promote it to Primary
On Workstations:
Start -> Settings -> Control Panel -> Network -> Identification
- Change Workstation to Domain ...
with Login as Administrator at Domain-Controller !!!
On Domain-Controller:
Start -> Programs -> Administrative Tools -> Server Manager
- select Backup Domain-Controller and promote it to Primary
30. Apr. 02