LEE
pi ee cee s Urs
eee uae
Brine
Refer to Wiring Diagrams Section 413-00, for schematic and connector
information.
General Equipment
Ford diagnostic equipment]
Instrument Cluster and Dimmable Backlighting
The dimmable illumination utilizes light emitting diodes (LEDs) and bulb(s).
The following dimmable components are backlit using LEDs only:
control panel
audio unit
instrument cluster
heater control panel
transmission control lever
hazard switch
traction control system disable switch
right-hand and left-hand heated front seat switch(es)
Inspection and Verification
1, Verify the customer concern,
2. Visually inspect for obvious signs of mechanical or electrical damage.
VISUAL INSPECTION CHART
Mechanical Electrical
‘+ Engine/engine compartment or ‘> Fuse(s)
underbody components + Loose or corroded connector(s)
+ Fluid levels ‘+ Instrument cluster
# Accessory installation + Switch(es)
+ Wiring Harness
+ Circuit(s)
+ LED(s)
3. If an obvious cause for an observed or reported concern is found, correct the cause (if
possible) before proceeding to the next step.
4, If the cause is not visually evident, verify the symptom and refer to the Symptom
Chart.
‘Symptom Chart
‘The table provides all possible symptoms related to the Suspension System. For a detailed
diagnosis, proceed to the Ford diagnostic equipment.
Symptom
[The control iumination Is inoperative
Possible Sources
[The instrument panel ilumination does not dim
[The Instrument cluster illumination is inoperative
[The climate control iMumination Is inoperativehe audio system control panel
llumination is inoperative ircuit(s) |
control panel