Mine dump truck BELAZ-7555B
of payload capacity 55 tonnes
It's designed for transportation of rock mass in difficult mining and technical conditions
of deep mines, at mineral deposit open pits on technological roads under various
climatic operating conditions (at ambient temperature from -50 to +50 °C).
Engine
Mode cummins KTA19<
Four-cycle gas-turbocharged and intercooled direct diesel engine with
in-line cylinders arrangement.
Rated power @ 2300 rpm, kW (hp) 522(710)
Maximum forgue @ 1400 rpm, N.m 23
Number of cylinders 6
Gylinders displacement | 189
Cylinder diameter, mm 358
Piston stroke, mm 159
Specific fuel consumption
atrated power, g/kW hr 209
‘Air cleaning is performed by three-stage filter with dry-type elements,
Engine exhaust expulsion is performed through body.
Vixed-type lubrication system is designed with "wet® crankcase
Fluid cooling system with forced circulation is integrated with cooling
system of hydromechanical transmission. Hydromechanica ransmission
all coating is performed by ol-to-water heat exchanger,
Starting system is actuated by electric starter.
Electric equipment system voltage, V 2%
Transmission
Hydromechanical transmission is equipped with complex one-stage four
wineeled torque converter with automatic locking, four-shaft gearbox
with fiction clutches and electrohydraulic actuator of gear change.
control, hydrodynamic blade-type retarder, automatic control and
protection system that provides command gear change.
Maximum dump truck travel speed, km/h
Hydramechanieal transmission 6+ gearbox ratios:
seas orward reverse
‘4070 4530
2865
2/045
1437
ou
oe
Suspension
Suspension is conventional for font axle and driving axle and equipped
with tailing ams, central joints and transversal rods. Cinders are
pneumohydralt (nitrogen and ol and ecuipped with mbit hydraulic
hock absorber. Two cylinders are on the font sale and ewe eying 76
onthe rear axe.
Gytinder piston stroke, mm
‘ont 300
i 0
Steering
Hycrestatic staring with sterable front wheels
Steering angle degree 4a
nd 3
Eee 203
The seeing acts 150 S010 requirements
Brakes
Dury truck brake system mets 1503450 intemational safety equlations
and requirements. The system equipped with service parking suxay
and emergency brake sytem
Service brake system is cry-type single-disk brake gears for front and
a eaey cia ceeeee elt atin
Reece ca eee een Reena
tive ving shaft with spring actuator and hyrauie contro.
sy esate yea care eat
raft acelted actation tare ad leche col
Puree eerste tree cece a
patie
Hydraulic system
Vai system combiond far body damping gear stewing ad bras
Bac ee rarer em re eee
tatascopi ody titg cpders with ane ste of ouble acon
Body lifting time, s 6
Body lowering time, 5 4
Maximum pressure in hydraulic system, MPa 7
Maximum pump delivery @ 2100 rpm, dm®/min 342
Filtration degree, mem 10Body
Welded bucket type body with FOPS safety system, protective canopy,
engine exhaust heating, device for mechanical fixing in raised position
and rock-ejectors
Body capacity, m
struck
2a7
223
heaped
333.
353 (optional)
Driving axle
Mechanical diving sxe is equipped with single-stage Bevel iv,
bevel ieentat nth our non ana planetary heb eves wth pur
Pinions.
Ratios:
final drive 273
hub drive 182
driving axle total 208
Driveline
Driveline consists of two open-type cardan shafts with joints on needle
bearings that join hydromechanical transmission to engine and driving
axle Flexible coupling is mounted between front cardan shaft and
‘engine. Front cardan shafts equipped with protective guard.
Cab
Two-man two-door cab is equipped with air-sprung adjustable diver seat,
additional passenger seat and adjustable steering column. The cab meets
EN 474-3 and EN 474-6 requirements that specify permissible Levels of
in-cab noise, vibration, content of hazardous substances and dust.
Driver's workplace meets ROPS safety requirements
In-eab noise level is nat mere than 89 dB(A)
Local vibration level is not more than 126 48 (A).
Overall vibration level is nat more than 115 dB(A).
Tires
Tubeless air tires with quany tread pattern,
ire designation 26.00-35 HC42/24,00835,
Inflation pressure, MPa 055/055,
Rim designation 17.00-35/3.5
Overall dimensions, mm*
swans)
aT
ET)
7555B
Frame
Frame is welded of high-strength low-alloy steel with application of cast
elements at the maximum loading points and equipped with box-section
‘ariable-height side-members interconnected by cross-members,
Maximum payload capacity, kg
Unladen weight, kg
Gross weight kg
Dump truck weight distribution on axles,
hloden laden
front Me Sao
mar iso 10
Refill capacities, |
Fuel tank vo
Eee coting ster ao
Engine aiestion sytem a
ijdromechancal eansmision so
Viva stem 300
Rearoe ioe
Fire-fighting system (standard) Special equipment
Heating and conditioning unit (standard)
Preneating system (optional
‘beliary eater for cab (optional)
Centralized lubrication system (optional)
System of loading and fuel control (optional)
“elemetering trepressure monitoring system (optional
Diagnostic system (optional)
[Altertion device of approach to high-woltage line (optional)
Body floor ining (optional)
ultiple-diskoltcooled brake for rear wheels and dry-type disk brakes
for front wheels, Actuators hydra and separate for fone and rear
wheel (optional)
Towing and braking performance
Towing perfomance
Braking perfomance
yea)
less
eater)
0 FF)
aaa] Bae,
Overall dimensions are spcifed for basic kttng-up ofthe dump truck
‘DISC ‘Belarusian Autoworks" (@ELAZ)
40 et Oktyabrya str, 4, 222160, Zoding, Republic of Slarus
phone: +375 1795 3:60:67, 3-97-37, 3-27-82
fax 13781778 1-01-47
femal: office @belaz.minsk.by
ve lazy