Perro.cuen DEVELOPMENT co,
Page 1 of 2
October 29, 1962
MECHANICAL SPECIFICATIONS — }
Se i
NE-62-1260-2
‘NE=62-1260-1, 0s pie - ;
Vacuum Heater
Vacuum Heater
OF Pertinent furnace dimensions see the attached drawings. i
EATING SURFACE
SOUL - See data sheet for size,
material and quantity of tubes,
coil is internal; convece:
Radiant
‘ton coil has return bends in head
ler box.
SOIL EITRINGS - Cast U-bends, See data sheet for type and material.
EXTENDED SURFACE - Upper 24 tubes of convection
EXTENDED SURFACE
fo be studded with 1/8" x 1/9" | up
B&H carbon stee
1 lens type studs,
TERMINAL CONNECTIONS - Beveled for welding.
TERMINAL CONNECTIONS
SHOP COTL FABRICATION - Coll welds shell be in accordance vith Petro-Chem
SHOP COTL FABRICATION
Pevelopment Company Specification TD-séa attached,
HERACTORIES AND INSULATION
HALL RADIANT SECTION - Four and one-half thick of insulating firebrick,
B&H-1620 or equal,
WALL CONVECTION SEOTION - Five inch thick gunnited refractory anchored
t ~ be peel plate, Refractory is a 1:4:8 mivece
of Lumite, Perlite and Zonolite, or equal.Berno.cuem peverormenr co. 1
Page 2 of 2
October 29, 1962
MECHANICAL SPECIFICATIONS
NE~62-1260-1
Yacuum Heater
EADIANT SECTION - Radiant tubes top supported by cast 25-12 Cr. Ni.
brackets bolted to shell.
/ONVECTION SECTION - Convection tubes are supported by 3/8" thick carbon
steel tube sheets, protected by 4" castable refractory
| on flue gas side.
BE GUIDES - Radiant tubes provided with lower alloy butterfly type.
STRUCTURE
Biri PLATES - Mild steel plate, 1/4" thick, per ASTM 4-283 Grade C or A~7.
Structural shapes per A-7.
ACK - 1/4! minimum plate thickness at top, same as shell material.
28S DOORS -, In''stack flare and floor when space permits, otherwise
*gecess in floor through burner opening.
fo shop assembled and shipped in three, main sections, namely radiant
‘Burners, arch firebrick, etc. shall be shipped for field