wie
4
ig
: ae
high fidelity phono cartridges
Ee eS
ius
_ sae 4 SHURE.Hee
The
all-important
source of sound
Shure | cartridges cise)
e “U Factor
billy isthe measure of a carttidge's total performance.
High Trackability enables the styius tip to folow the hype:
‘complex tecoxc groove up fo andlbeyond the theoretical cutting
limits of foday's madien recordings —not only ata select cn
crete frequency, bul across he entre audible specttum — al
light tracking forces that ate below both the thneshoid of
‘qudibie record wer and excessive stylus tip wet
Inthe graph dbove, the shaded ares repiesents recommended
theoretical limits of recor cutting velocities The scattered points
‘are the "hottest" recoided velooilies actually measured on
iificul-o-ttack records. Athough a eartrides with modercie
‘rackabilty will be able to rack alle tecorced velocities
‘encompassed within the theoretical cutting sty iis,
substantially high rackabilly sneededifo hock recorded
velocities actualy found on today's dses. The Vib Type IV tracks
mote of he “holtest” points at alow stylus force than any other
‘cattrcge, The curve shown is for] gram tracking force. By
increasing the tracking force to}}/4 grams, even mote of hese
points — virtually all cord produced thus far— willbe ee}
Dd bad
The cbove left photomicrograph shows a record of musical
‘matetiol cut at ioday's “hotter” velocities afferonly one play with
combine; ova na iah ptaerce ed echyes
{the Shao Vis pol who spac tel euoconognohs sae
Slane encnpona Rockobity Se wera plone
The OSE noorpcrfer new nne: unneruple poleplace dewloped
Dy Shue dad ongrest fo optrizeslactomagrais xaoctatces
‘Sipacialy at gherfequencias Asa teu. mograislowss eve bean
mrinened. ona equercy tesperte lara erly fet cos he ere
ffequoncy range. Gmamicronge spay oMerced.
vin esrusemountea, Brocka lpia sus, ho MPSEO Nas very ow
Sate sus ip mess ns sowtos higher tacucbaty 9 rartan portoct
{leowecortoc rough he -hote mos heal mosucied posages
recurred on medern recaeings — al exomely ig Racking aco:
fhot cr esord woot end nexeose aus tp fe oxcopteral WIOOIY
Tes the MBEED en oustoneing chloe or use nfourchartas esaced
Tne ore.
TRACKABIUITY CHART
tances)
M9SEJ Specifications
‘Yockebily at 2 groms rocking ee in
‘peak ecotded vloaty) wing
‘Shara/SME Arm:
2B.om seco 400K
S5emn/secot 1000hz
en swe ot OOO HE Se
‘Wacking Force: H1/2%03 gems
Frequency Response: 200 20000 2
‘Optimum Load: 47 000 ohms resstance
Inport win 400 S0Opicotarads oto
‘capactance per chonnst. Loo
‘esslonce cor be up 12 100,000 ohms ont
{otal eapactance con be aslow 100
‘Bootorod wih ony min ouciols
hangs. otal capgceance includes tho
apoctonces of ho tone am wif
[Ghoro ccbles ond ompter epxt cheut
‘Ouiput Votlage: 47 mV pet channel ot
00D Ma ct Sem sec peak recorded
vyooty | replacement vis
‘Channel Separation: Niniim 20.6 ot
Yo0D: formonapnoric 78 om
Charme! Balance: Oulpuomeach recordings
hornet tin 2
te
fecar contact pots
cenatnsipros
Weight: 63ga7
mowing corer:
Sivas N9SEs Bracaleipsca laren
Vk mictons (0007 ro) eral ads
TOrmors (0004 neh) 8 carton!
BBmicrore (O00 ch) wide between
Sus N25 Sproat monoptonic
Peter roccrsings~ 63 mixers (0025
Inavetance: é50 mtnentes
Dc Resistance: 1550 tre
Mounting: toncora 127m (12 ren)
MODEL MASE Custom Hi rock Comicon
wh crs pial aye
MODEL W286) arose’ Elec
MODEL NA Sonera! ya elgnec
Second only to the Super Track
series for stereo
M95ED Specifications
Trackabitty ot gam rockin face
(inom sec peck tesco veooty)
tinge shu SME Am
Dan ano ataoc ne
‘Son sect oun
‘Smcrons (0002 nh) sto
‘ntact os
25 miore (O70 inch) wide
atwean cord cortaa ois
Stylus NESS spherical ss (as
i peer
Beer sec at Om ‘tne omisor S05)
Syed Sys tp sts
tosking Face! 9/4t011/ 290m
Recwkyserpone ees eiNe | SYMENEES Soha
‘Optimum Load 47 020 o¥rns
feutones Inpro lh ACD 0
Sons es on st
Inductance: 650 miherses
Dc Rewstance: 580 rms
Welgtt:63 grams
Mourtng: tress 12 (V2
pen) mening carts
USenatpnans [MODEL MRSED Det H-Fock
wera preocobn ora oreer Delve iF
Ekiputvonage: 47 mv perchomet Ss eco
000s 3 cmon ose MODEL MPEG Deke H-took
‘eooded velocity ‘Comoe win Spherics
‘Channe! separation: Minimum 25 Svs 0095
‘Gber ooo MODEL NOSED Brox Bipico
‘Chonnelfolonce:Cutputtemeach replacement hive $3170
| Senna wien? cB MODEL N9SG Spneical replacement
| SiytUE NEED Brodtol Eiptest nude aks 15
‘Serovar MODEL N9S-3 Sphotice sts
Tmo (007 renter "der rents
roche 290
M9SEJ Custom high trackability cartridge with builtin
snap-down stylus guard and Biradial Eliptical stylus
For 1-1/2 to 3 Grams Tracking
Designed specttically for owners of heavier tracking
(0-1/2 to 3 grams) turntables and tone arms who want
‘optimum cartridge performance, The M9SEJ uses the
same newly developed pole piece of the M9SED
forces,
The M9S5EJ uses a Biradial Elliptical stylus tip, and
choice for audiophiles who want fo upgrade their
record playback systems af moderate cost
TRACKABIUTY CHART
(arzcens)
sor
2598
230
(obove) and delivers « frequency response virtually
identical in ts flatness —but at slightly areater tracking
delivers excellent frackabilt It is the ideal cartridgeDeluxe series of high 2
trackability cartridges
For 3/4 to 1-1/2 Grams Tracking
M7SED Type 2
Elliptical Syius Biradial Elliptical Stylus with
MGIGD Spherical Slyius Buil-in Snap-down Stylus Guard
(Optimized design parameters in he siius assembly give these Deluxe
Series cartridges super high frequency trackobilty, and overall
Perormanee previously unavailable at tis pric lave
The ulraight diamond sty tip on these caatridges is
nude: mounted ditectly on the stylus bar, reducing effective
stylus tip mass and heightening is excellent racking
Characteristics. The very high frackabily levels reached by
these cartridges make them suitable choices for use in
fourchannel encoded (matrix) playback systems.
The MIIED, M9IGD and M75ED Type 2 have identical
performance characteristics, The M7ED Type 2 is offered
‘or those who prefer a bullin snap-