Kindly calculate the vessel min thickness with the
stated formular to validate the name plate info as
vessel material is known now based on the PMI test and share the calculation sheet Attachment 2 NGC DELTA IV METERING STATION PRESSURE VESSEL DESIGN REPORT CALCULATION SHEET
1. INLET FILTER VESSEL
Material Stress at Min Messured Design Thk
Vessel Diameter Design Pressure O Joint thk Tact (mm) Tmin (mm)* Design Temp ( C) Material grade Stress Range Design (mm) (Bar) Safety Efficiency (Mpa) Temp (Mpa) Factor Head Shell Head Shell 711 118.36 148 A285 GR B 345 to 485 98.6 3.5 1 37.86 34.45 27.5 28.5 Minimum Design Wall Thickness formular, Shell: tmin =PR/SE+0.4P ; HEAD=PD/2SE-0.2P (FROM ASME VIII Part UG27, DESIGN CODE) .Where P=Internal Design Pressure, D=Vessel Daimeter (R= Internal Radius), S= Maximum Allowable Stress According to ASME Section II Part D, E = Welding Factor (1.0 for seamless pipe; 0.85 = for welded pipe), C = Corrosion Allowance (0 for no corrosion, 1.5 commonly used as Minimum) Note: Design Safety Factor of 3.5 was assumed *: FOR INLET FILTER VESSEL, THE DESIGN MINIMUM THICKNESS WAS NOT CALCULATED BUT WAS GOTTEN FROM VESSEL NAME PLATE
Weld Quality: The Role of Computers: Proceedings of the International Conference on Improved Weldment Control with Special Reference to Computer Technology Held in Vienna, Austria, 4–5 July 1988 under the Auspices of the International Institute of Welding