_ - STK-1050
)
SANYO
50 W MIN. AF POWER AMPLIFIER OUTPUT STAGE (DPP)
INTEGRATED EMITTER RESISTOR
THICK FILM HYBRID INTEGRATED CIRCUIT
FEATURES
+ Does not require externally connected emitter resistors.
+ Values of emitter resistors have carefully been reviewed to provide superior characteristics.
a, Better supply voltage utilization permits designing power supply voltages that are #0.7 V (for Ry = 42) lower
‘than those required for previous DPP models.
b. Maximum allowable power
loads.
consumption for each resistor is 5 W or higher, permitting accommodation for all
c. Peak allowable current is 18 A or more, providing an ample margin even for peak currents under when short
circuited or similar emergencies.
4d. In particular, maximum outputs 422 have been enormously improved.
+ Use of emitter resistors facilitates meeting deferent safety standards and designing PCBs.
+ Mutual interferences in the high-frequency range caused by layout of externally connected emitter resistors no
longer exist. This facilitates lower distortion factors.”
+ Pins are used for emitter resistor output terminals that were not connected in previous DPPs. All other terminals
remain unchanged; there is no need for major circuit board changes.
MAXIMUM RATINGS/T, = 25°C
Maximum power supply voltage
‘Thermal resistance
Collector current
Junetion temperature
‘Storage ambient temperature
Short-cirouit load allowable time
Recommended power supply
voltage
unit
Vec max #30 OV
Bic ‘Ideal dissipating condition 1.8 “CW
le 7 OA
7 160 °C.
Tstq -20~+105 °C
ts Voc=#36V",f=50Hz, 2 sec
RL =82, Po = 50W
“Employ specified
transformer power supply
RECOMMENDED OPERATING CONDITIONS/T, = 25°C unit
Vee #360 OV
RL 8 2
Load resistance
2 ‘
4
+ Kk
Tl
Equivalent circiit ¥ I
ne
ea mm
A
BR ok
we
s
fm Sp baw
;STK-1050
OPERATING CHARACTERISTICS/Ta = 25°, Vcc = #36 V, RL = 82, Rg = 6000, VG = 26.348, at specified test
circuit (conforming with sample appli
min typ max unit
No signal current leco Veo= #43 20 40 «80 «mA
50 w
min typ max unit
Output power 50 w
Po (2) Voc = #31 V, THD = 0.03%, 55 w
fe TkHz, RL=42.
Total harmonic distortion THD Po=1~S0W, f=20Hz~20kHz 002%
Emitter resistor Re o1g 022 020 2
*To test for short-circuit allowable time, use a transformer power supply specified in diagram at the right.
a0
fe a aie
Specified transformer power supply
(Sansui RP-36 or equivalent)
(Tango MG-200 or equivalent)
|= SAMPLE APPLICATION CIRCUIT: 50 W min. AF Power Amplifier
fhe
“GP
a ole - aay
mentel |
a7 | Lam T
6 *F 7
asap |tNon-inductive)
cd