Professional Documents
Culture Documents
6 DOHC > Automatic Transaxle System > Automatic Transaxle Control System > Output Speed Sensor > Repair procedures
Removal
1. Remove the battery terminal.
2. Remove the battery and battery tray.
3. Remove the air duct.
4. Remove the air cleaner assembly. (Refer to Automatic transaxle's Removal)
5. Remove the output speed sensor connector(A).
Installation
1. Install the new O-ring to the output speed sensor.
2. Remove the output speed sensor (A).
Tightening torque :
10~12N.m(1.0~1.2kgf.m, 7~8lb-ft)
While installing the output speed sensor, do not allow dust or other foreign particles to enter the
transaxle.
1/2
G 1.6 DOHC > Automatic Transaxle System > Automatic Transaxle Control System > Output Speed Sensor > Repair procedures
3. Check the connector for dust, dirt, or oil, then connect the output speed sensor connector (A)
securely.
2/2