Professional Documents
Culture Documents
(/)
Login (/login-user)
Register (/register)
You are here: Home (/) Dimensions (/dimensions-and-weights) Pipe Dimensions (/pipe-dimensions)
Table below provides dimensions of HDPE pipes for PE100 material of rating PN16, SDR 11 or S5. The following
section provides a brief background of the various definitions used and the applicable calculations while
referring to PE pipes.
OutsideDiameter
As per EN 12201 SDR (Standard Dimension Ratio) =
W allT hickness
..........(1)
..........(2)
20σ
PN Rating of SDR pipe is calculated using the formula PN =
(SDR−1)
where the maximum allowable structural stress or hydrostatic design stress σ is determined from the MRS
ISO 4427 covers three material grades: PE63, PE80 and PE100. The MRS for PE63, PE80 and PE100 pipe are
6.3Mpa, 8.0MPa and 10.0MPa respectively. As per ISO 4427, the minimum design safety factor or overall service
(SDR−1)
The polyethene pipe series is expressed as S =
2
..........(3)
(11−1)
Using equation (3) SDR of 11 corresponds to S series = = S 5.
2
Based on the above formulas, a higher wall thickness translates into lower SDR values, lower S values and
Table of HDPE Pipe Sizes and wall thickness for PE 100 | SDR 11 | PN16 | S5 pipe
Maximum pipe wall thickness = Nominal size - Average ID - Minimum wall thickness.
Industry Standards
ISO 4427-1: Plastics piping systems for water supply and for drainage and sewerage under pressure -
Polyethylene (PE) - Part 1: General
ISO 4427-2: Plastics piping systems for water supply, and for drainage and sewerage under pressure -
Polyethylene (PE) - Part2: Pipes
ISO 4427-3: Plastics piping systems for water supply, and for drainage and sewerage under pressure -
ASTM F714: Standard Specification for Polyethylene (PE) Plastic Pipe (DR-PR) Based on Outside Diameter
EN 12201-2: Plastics piping systems for water supply - Polyethylene - Part 2: Pipes
EN 1555-2: Plastics piping systems for the supply of gaseous fuels - Polyethylene - Part 2: Pipes
ISO 4437-2: Plastics piping systems for the supply of gaseous fuels - Polyethylene - Part 2: Pipes
This website uses cookies to enhance user experience and provide the most relevant content. Accept Privacy Policy x
Dimensions and Weights of Carbon Steel pipes (/dimensions-and-weights-of-carbon-steel-pipes)
(https://www.piping-world.com/privacy-policy) /
Dimensions of 16 bar rating Cu-Ni Pipes (Tubes) (/dimension-of-16-bar-rating-cu-ni-pipes-tubes)
HDPE Pipe Dimensions and Weights - PE100 PN12.5 SDR 13.6 (/hdpe-pipe-dimensions-and-weights-pe100-pn12-5-sdr-13-6)
HDPE Pipe Dimensions and Weights - PE100 PN25 SDR 7.4 (/hdpe-pipe-dimensions-and-weights-pe100-pn25-sdr-7-4)
Polyethylene Lining/Coating
OPEN
This website uses cookies to enhance user experience and provide the most relevant content. Accept Privacy Policy x
(https://www.piping-world.com/privacy-policy) /