Professional Documents
Culture Documents
COM
1. Mixer stage
2. Power stage
3. Detector stage
4. F stage
Answer : 2
1. Transformer
2. RC
3. direct
4. Impedance
Answer : 1
1. Two transistors
2. Three transistors
3. One transistor
4. None of the above
Answer : 3
Q4. The maximum efficiency of resistance loaded class A power amplifier is ……..
1. 5%
2. 50%
3. 30%
4. 25%
Answer : 4
1. 30%
2. 50%
3. 80%
4. 45%
Answer : 2
1. C
2. A
3. B
4. AB
Answer : 1
1. Small
2. Very small
3. Large
4. None of the above
Answer : 3
Q8. In class A operation, the operating point is generally located ………. of the d.c. load
line.
Answer : 2
1. AF amplifiers
2. Detectors
3. F. amplifiers
4. None of the above
Answer : 3
1. Small
2. Large
3. Very large
4. None of the above
Answer : 1
1. 50%
2. 90%
3. 5%
4. 5%
WWW.ALLEXAMREVIEW.COM
Answer : 4
1. Dual
2. Push-pull
3. Symmetrical
4. Differential
Answer : 2
Q13. If a transistor is operated in such a way that output current flows for 60o of the input
signal, then it is …………… operation
1. Class A
2. Class B
3. Class C
4. None of the above
Answer : 3
Q14. If the zero signal dissipation of a transistor is 1W, then power rating of the transistor
should be at least ……………….
1. 5W
2. 33 W
3. 75 W
4. 1W
Answer : 4
Answer : 1
1. Symmetrical
2. Single-ended
3. Reciprocating
4. Differential
Answer : 2
1. A
2. B
3. C
4. AB
Answer : 3
1. Push-pull amplifier
2. Preamplifier
3. Class A power amplifier
4. None of the above
Answer : 1
Answer : 2
Answer : 3
Answer : 1
Q22. If the power rating of a transistor is 1W and collector current is 100mA, then
maximum allowable collector voltage is ………..
1. 1V
2. 100V
3. 20V
4. 10V
WWW.ALLEXAMREVIEW.COM
Answer : 4
Q23. When no signal is applied, the approximate collector efficiency of class A power
amplifier is …….
1. 10%
2. 0%
3. 25%
4. 50%
Answer : 2
Q24. What will be the collector efficiency of a power amplifier having zero signal power
dissipation of 5 watts and a.c. power output of 2 watts?
1. 20%
2. 80%
3. 40%
4. 50%
Answer : 3
Q25. The output signal voltage and current of a power amplifier are 5V and 200 mA; the
values being r.m.s. What is the power output?
1. 1W
2. 2W
3. 4W
4. None of the above
Answer : 1
Q26. The maximum a.c. power output from a class A power amplifier is 10 W. What should
be the minimum power rating of the transistor used ?
1. 10 W
2. 15 W
3. 5W
4. 20 W
Answer : 4
Q27. For the same a.c. power output as above, what should be the minimum power rating of
transistor for class B operation?
1. 10 W
2. 4W
3. 8W
4. None of the above
Answer : 2
WWW.ALLEXAMREVIEW.COM
1. Class A
2. Class C
3. Class B
4. Class AB
Answer : 3
Q29. The class B push-pull circuit can deliver 100 W of a.c. output power. What should be
the minimum power rating of each transistor?
1. 20 W
2. 40 W
3. 10 W
4. 80 W
Answer : 1
1. 2
2. 7
3. 3
4. None of the above
Answer : 2
Q31. A transformer coupled class A power amplifier has a load of 100 Ω on the secondary.
If the turn ratio is 10:1, what is the value of load appearing on the primary?
1. 5 kΩ
2. 20 kΩ
3. 100 kΩ
4. 10 kΩ
Answer : 4
Answer : 2
Answer : 1
1. 1:1 ratio
2. Step-up
3. Step-down
4. None of the above
Answer : 3
Answer : 2
Answer : 3
1. Burning of transistor
2. Hum in the circuit
3. Excessive forward voltage
4. None of the above
Answer : 2
Answer : 1
WWW.ALLEXAMREVIEW.COM
Q39. If the gain versus frequency curve of a transistor amplifier is not flat, then there is
distortion.
1. Amplitude
2. Intermodulation
3. Frequency
4. None of the above
Answer : 3
1. RC
2. Direct
3. Impedance
4. Transformer
Answer : 4