Professional Documents
Culture Documents
BBSG24MP F/W & S/W Update Via USB Stick: Update DSP Runtime Software
BBSG24MP F/W & S/W Update Via USB Stick: Update DSP Runtime Software
Please note that by using and / or updating the BBSG24MP software or firmware you are agreeing to
the terms of the JoeCo Software Licence Agreement. The licence agreement can be found in the
User Manual or under the support tab on www.joeco.co.uk
Copy update-sg v3.5.0.0.bbr1 file into root folder of a FAT32 formatted USB2/3 stick
[A] With BB front panel buttons and wheel or PS2 keyboard navigate on BB LCD screen to
Main Menu -> update -> Permit -> any system update
Update writing and verifying takes a minute or so – progress is shown on the LCD.
If there was an error re-power and try again from [A] point above.
If a USB stick is not “seen” by BB try a different type/size as there may be the odd rogue type which
is not fully compatible.
[B] With BB front panel buttons and wheel or PS2 keyboard navigate on BB LCD screen to
BB asks to be re-powered
Re-power BB which will start into Firmware update mode as shown on LCD screen
1
The number in the filename “update-sg v3.5.0.0.bbr” reflects the version number of the software update file.
2
The FPGA firmware update filename “update-bbsg24mp-io-vE_12apr18.bbr” reflects the version number “E”
and the date it was created “12 April 2018” in this example
JoeCo Ltd, 135 Histon Road, Cottenham, Cambridge, CB24 8UQ UK. Tel: +44 (0)1223 911000 Email: mail@joeco.co.uk Web: www.joeco.co.uk 1
When message on LCD screen invites you to “Insert update” in red text then plug in the USB stick.
FPGA update will not be offered if you plug the disk in too early (i.e. before screen message). It is
best to wait for a few seconds after the message appears before plugging in the USB stick
System will then scan the disk and offers update file
Accept the update (using MENU button) which then proceeds for about a minute.
Notes:
1) FPGA update will not proceed if the update file is found to be identical to current FPGA
configuration.
Check versions
On BB LCD
This page reports the current DSP runtime s/w on the second line which after this update should
read:
v3.5.0.0
FPGA firmware is reported in the blue text on the fourth line and should read
BB Firmware version E
[end of doc]
JoeCo Ltd, 135 Histon Road, Cottenham, Cambridge, CB24 8UQ UK. Tel: +44 (0)1223 911000 Email: mail@joeco.co.uk Web: www.joeco.co.uk 2