Professional Documents
Culture Documents
ADVANCED POWER S…
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Finish review
Started on
Saturday, 24 April 2021, 2:00 PM
State
Finished
Completed on
Saturday, 24 April 2021, 2:18 PM
Time taken
17 mins 59 secs
Grade
14 out of 15 (93
93%)
:
QUESTION 1
Correct
Mark 1 out of 1
a.
b. !
c.
d.
Mark 1 out of 1
a. 0 !
b. 1
c. None
d. 3
Mark 0 out of 1
a. None
b.
c. "
d.
Mark 1 out of 1
a.
b. 1
c. 0 !
d.
QUESTION 5
Correct
Mark 1 out of 1
Mark 1 out of 1
a. 1/3
b. 3
c. 0 !
d. 1
Mark 1 out of 1
a. 0
b. /6
c. !
d.
QUESTION 8
Correct
Mark 1 out of 1
a.
:
b.
c. !
d.
Mark 1 out of 1
a.
b. !
c.
d.
QUESTION 10
Correct
Mark 1 out of 1
a. 1
b. -1
c. in!nite
d. 0 !
Mark 1 out of 1
d. None
QUESTION 12
Correct
Mark 1 out of 1
Mark 1 out of 1
If positive, negative and zero sequence reactances of an element of power system are 0.3 pu, 0.3 pu and 0.8 pu
respectively, then element would be
a. Static load
b. Synchronous generator
c. Transmission line !
d. Synchronous motor
QUESTION 14
Correct
Mark 1 out of 1
a. !
b.
c.
d.
Mark 1 out of 1
b. Always zero
Jump to...
Contact
https://virtual.uol.edu.pk/
:
UOL
# $
ADVANCED POWER S…
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Finish review
Started on
Saturday, 22 May 2021, 2:00 PM
State
Finished
Completed on
Saturday, 22 May 2021, 2:17 PM
Time taken
17 mins 25 secs
Grade
13 out of 15 (87
87%)
:
QUESTION 1
Correct
Mark 1 out of 1
The circuit given below is the Thevenin equivalent of sequence networks for
QUESTION 2
Correct
Mark 1 out of 1
a. 1
b. 3Zn
c. in!nite
d. 0 !
Mark 1 out of 1
QUESTION 4
Correct
Mark 1 out of 1
What are the terminal conditions in case of single line to ground fault, if the fault occurs in the phase A?
a. Vb = 0, Ia = 0, Ic = 0
b. Vb = 0, Ia = 0, Ib = 0
c. Va = 0, Ia = 0, Ic = 0
d. Va = 0, Ib = 0, Ic = 0 !
Mark 0 out of 1
Which of the following is the Thevenin equivalent positive sequence network for an open conductor fault on a
section of a three-phase system between buses m and n on phase A.
a. c
b. b
d. a "
QUESTION 6
Correct
Mark 1 out of 1
:
Which among these is the connection diagram for line to line fault?
a. d
b. c
c. b
d. a !
Mark 1 out of 1
In which type of fault, positive sequence and negative sequence voltages are equal
d. None
Mark 1 out of 1
Mark 1 out of 1
What is the value of fault current If , in case of single line to ground fault?
a.
b. !
c.
d. None
Mark 0 out of 1
The sequence currents recorded in a power system under a fault condition are
Ipositive = j1.923 pu, Inegative = – j0.8 pu, Izero = – j1.246 pu.
The fault is
d. None
Mark 1 out of 1
Which among these is the connection diagram, in case of single line to ground fault?
a. a !
b. b
c. c
d. d
Mark 1 out of 1
a. Negative sequence
b. Zero sequence !
c. Positive sequence
d. None
Mark 1 out of 1
a.
b.
c. !
QUESTION 14
Correct
Mark 1 out of 1
What happens if the neutral is not grounded in case of the single line to ground fault?
c. None
d. The zero sequence impedance will be in!nite and Fault current will be zero. !
Mark 1 out of 1
For a single line to ground fault the value of zero sequence current is 3j pu. The current carried by the fault is
a. 6j pu
b. 3j pu
c. 1j pu
d. 9j pu !
Jump to...
Contact
https://virtual.uol.edu.pk/
:
UOL
# $
ADVANCED POWER S…
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
Finish review
Started on
Saturday, 10 April 2021, 10:00 AM
State
Finished
Completed on
Saturday, 10 April 2021, 10:18 AM
Time taken
18 mins 33 secs
Grade
17 out of 20 (85
85%)
:
QUESTION 1
Correct
Mark 1 out of 1
a. Quadratic convergence !
b. None
c. Linear convergence
d. Cubic convergence
Mark 1 out of 1
d. none
Mark 0 out of 1
b. Phase angle
QUESTION 4
Correct
Mark 1 out of 1
a. A branch of value Zb is added in the original network between two di"erent nodes.
b. None
c. A branch of value Zb is added in the original network from a new node to existing node. !
d. A branch of value Zb is added in the original network from a new node to reference node.
Mark 1 out of 1
QUESTION 6
Correct
Mark 1 out of 1
A network containing 50 buses in which 10 are the voltage control buses, 6 are the generator buses. Find the
size of the Jacobian matrix?
a. 33× 33
b. 83× 83 !
c. 84× 84
d. 34× 34
Mark 1 out of 1
In a load flow analysis of a power system, the load connected at a bus is represented as
QUESTION 8
Correct
Mark 1 out of 1
Which among the following buses constitute the maximum number in a power system?
a. Slack bus
b. None
c. P Q bus !
d. P V bus
Mark 1 out of 1
b. Parallel RL circuit
c. Series RL circuit !
QUESTION 10
Correct
Mark 1 out of 1
In a synchronous generator for how much time subtransient period of symmetrical short circuit current lasts?
a. For 2 Cycles !
d. For 30 Cycles
Mark 0 out of 1
Select one:
True "
False
QUESTION 12
Correct
Mark 1 out of 1
In a load flow problem solved by newton-Raphson method with polar coordinates, the size of the Jacobian is
100 × 100. If there are 20 PV buses in addition to PQ buses and a slack bus, the total number of buses in the
system is__________.
a. 61 !
b. 51
c. 55
d. 71
Mark 1 out of 1
a. 15.5 to 20.2
b. 1.6 to 1.8 !
c. 20 to 30
d.
10 to 20
QUESTION 14
Incorrect
Mark 0 out of 1
b. None "
Mark 1 out of 1
QUESTION 16
Correct
Mark 1 out of 1
Mark 1 out of 1
Select one:
True
False !
QUESTION 18
Correct
Mark 1 out of 1
Mark 1 out of 1
Mark 1 out of 1
In a 100 bus power system, there are 10 generators. In a particular iteration of Newton Raphson load flow
technique (in polar coordinates), two of the PV buses are converted to PQ type. In this iteration,
a. the number of unknown voltage angles remains unchanged and the number of unknown voltage magnitudes !
increases by two.
b. the number of unknown voltage angles increases by two and the number of unknown voltage magnitudes increases by
two.
c. the number of unknown voltage angles remains unchanged and the number of unknown voltage magnitudes decreases
by two.
d. the number of unknown voltage angles increases by two and the number of unknown voltage magnitudes decreases by
two.
◀ Attendance
Jump to...
Contact
https://virtual.uol.edu.pk/
:
UOL
# $