You are on page 1of 8

411

Producing proteins in transgenic plants and animals


James W Larrick*† and David W Thomas†
The requirement for large quantities of therapeutic proteins has many advantages as sources of proteins compared with
fuelled interest in the production of recombinant proteins in human or animal fluids/tissues, recombinant microbes,
plants and animals. The first commercial products to be made transfected animal cell lines or transgenic animals. First,
in this way have experienced much success, and it is predicted the cost of producing raw material on an agricultural scale
that in the future a plethora of protein products will be made is low and there is the possibility, in some cases, of using
using these ‘natural’ bioreactors. the edible plant material directly. Second, the use of plants
offers reduced capitalization costs relative to fermentation
Addresses methods. Third, production can be rapidly up-scaled.
*Planet Biotechnology, Inc., 2438 Wyandotte Street, Mountain View, Fourth, unlike bacteria, plants can produce multimeric
CA 94043, USA; e-mail: jwlarrick@aol.com proteins, such as antibodies, in the correct assembly. Fifth,
† Palo Alto Institute of Molecular Medicine, 2462 Wyandotte Street,
Mountain View, CA 94043, USA
plant proteins are considered to be safer, as plants do not
serve as hosts for human pathogens such as human
Current Opinion in Biotechnology 2001, 12:411–418 immunodeficiency virus (HIV), prions, hepatitis viruses
0958-1669/01/$ — see front matter and so on. This final point is noteworthy, given the spread
© 2001 Elsevier Science Ltd. All rights reserved. of foot-and-mouth disease and bovine spongiform
encephalopathy from the United Kingdom into Europe.
Abbreviations
AAT α1-antitrypsin
HC-Pro helper-component proteinase Depending upon the promoters used, transgenic proteins
PTGS post-transcriptional gene silencing can be deposited throughout the plant, in specific parts of
TSP total soluble protein the plant (e.g. in seeds) or in specific plant cell organelles
(e.g. chloroplasts) within a given plant cell. Numerous lab-
Introduction oratories have shown transgenic protein accumulation in
The inexpensive production for large quantities (many seed of corn [24,25], soybean [3], tobacco [26] or barley
kilograms) of protein has led to a new industry to produce [27•]. Proteins produced in seed exhibit remarkable stabil-
recombinant proteins in transgenic plants and animals. ity; for example, enzymes and antibodies expressed in
The potential of ‘molecular pharming’, using transgenic seed and stored for more than three years at refrigerator
plants or animals as ‘bioreactors’ to produce therapeutic temperature retain full enzymatic or binding activity.
proteins, has been apparent for over a decade and several Recently, success was reported using tropical plants, such
proteins produced in these systems are now in clinical tri- as cassava (Manihot esculenta Crantz) [28•] and banana [29].
als. Depending on the production system used, there are This opens up the possibility of delivering oral vaccines
several issues of concern. Animal systems suffer from long and recombinant pharmaceuticals directly to consumers in
development timelines and possible contamination of less developed equatorial countries.
purified proteins with animal viruses and prions. Plant-
produced proteins have altered post-translational modifi- In the past year, notable advances have been made using
cations that introduce novel carbohydrates. Here, we chloroplast expression of recombinant proteins. A foreign
review the most recent advances in these technologies and gene is introduced into a spacer region between the
discuss the methods that are being developed to functional genes of the chloroplast using homologous
overcome these concerns. recombination. This eliminates position effects of nuclear
transformation, and gene silencing has not been a problem.
Plant expression Staub et al., [30••] demonstrated that chloroplasts can
Technological advances using plant bioreactors process and fully assemble a disulfide-bonded form of
Plants provide an attractive expression vehicle for numer- human somatotropin (expressed as 7% of the total soluble
ous proteins (see Table 1) [1–14]. Plant ‘bioreactors’ are protein [TSP]) and an oligomeric form of cholera toxin B
expected to yield over 10 kg of therapeutic protein per acre (4–5% TSP). Henriques and Daniell [31] expressed
in tobacco, maize, soybean and alfalfa [15,16•]. Compared foreign genes (up to 10,000 copies/cell) in tobacco chloro-
with the use of conventional steel tank bioreactors and plasts, resulting in the accumulation of foreign proteins
mammalian cells or microorganisms, the cost of producing that comprise up to 47% of the TSP [32].
a protein under good manufacturing practice (GMP)
conditions is reduced to perhaps one-tenth. A novel Tobravirus-based system [33] for root expression
was reported last year, and new vector technologies contin-
Recent research demonstrates that plants will provide a ue to be developed. For example, internal ribosome entry
facile and economic bioreactor for the large-scale produc- sites (IRES) have been used to direct the expression of
tion of industrial and pharmaceutical recombinant proteins bicistronic mRNA [34] and Dow AgroSciences described an
[15,17–23]. Genetically engineered, transgenic plants have adenosine deaminase selection system for maize [35].
412 Protein technologies and commercial enzymes

Table 1 and α(1,3)-fucose have been linked to specific IgE in


serum and to biological activity (i.e. histamine release) in
Representative therapeutic proteins produced in transgenic
plants. allergic patients [37,38]. In contrast, however, the mere
presence of serum IgE against cross-reactive carbohydrate
Recombinant proteins Plants Reference/group determinants, which include the β(1,2)-xylose and
α(1,3)-fucose linkages to the core Man3GlcNAc2 of plant
Antibodies
SIgA anti-S. mutans Tobacco [1,2] glycans, has been shown to be a poor predictor of clinical
Planet Biotechnology allergy [39–41]. These results preclude generalities about
Hayward, CA the potential toxicity of plantibody glycans in humans.
IgG anti-herpes simplex Soybean [3]
virus Monsanto,
St Louis, MO
When a mouse plantibody (mouse amino acid sequence
Various antibodies Maize/rice EPIcyte, and plant glycans) was used to immunize mice there was
San Diego, CA no, or only a minimally detectable, serum immune
Anti-carcinoembryonic Rice and wheat [88] response. Thus, in the mouse at least, a ‘self’ primary
antigen
protein structure decorated with plant N-linked glycans
Lymphoma idiotypes Tobacco [89]
can be non-immunogenic. This plantibody has been
Vaccines applied topically in the mouth of humans with no
Hepatitis B surface antigen Tobacco [4–6]
Rabies vaccine Tobacco [90] detection of human antimouse antibodies [2].
Norwalk capsid protein Tobacco, potato [7]
Porcine transmissible Tobacco [63] Recent efforts have focused on the humanization of plant
gastroenteritis virus glycans to reduce their immunogenic potential. Comparison
E. coli toxin (LT-B) Potato [8–10]
Cholera toxin (CT-B) Potato [11,12]
of plant and mammalian N-glycan biosynthesis indicates
Mouse GAD67 Potato [13] that β1,4-galactosyltransferase is the most important
VP2 capsid protein of mink Black-eyed bean, [14] enzyme that is missing for conversion of typical plant
enteritis virus inserted into Vigna unguiculata N-glycans into mammalian-like N-glycans. Bakker et al. [42]
cowpea mosaic virus
reported the stable expression of human β1,4-galactosyl-
Other proteins transferase in tobacco plants. Crossing a tobacco plant
Collagen Tobacco [56•]
Hirudin Canola, Sembiosys Calgary,
expressing human β1,4-galactosyltransferase with a plant
(Brassica napus) Alberta, Canada expressing the heavy- and light-chains of a mouse antibody
Lactoferrin Potato [55] resulted in the expression of a plantibody that exhibits
Lipase Tobacco, maize Meristem Therapeutics partially galactosylated N-glycans (30%). This level of
Clermont Ferrand,
carbohydrate incorporation is approximately as abundant as
France
Growth hormone Tobacco [30••] when the same antibody is produced by hybridoma cells.
Erythropoietin Tobacco [17] These results represent a major step forward in the engi-
neering of the N-glycosylation of recombinant proteins.
Aglycosylated antibodies lacking carbohydrates altogether
can also be created by altering the peptide recognition
Issues regarding protein production in plants sequence for N-linked glycosylation (Asn-X-Ser/Thr). High-
Glycosylation mannose-type glycosylation, which does not contain the
Differences in the glycosylation patterns of proteins core-linked xylose and fucose residues, may be favored by
produced in plants and humans give perhaps most cause for the addition of a C-terminal Lys-Asp-Glu-Leu sequence
concern regarding therapeutic protein production. [43] and the subsequent targeting of proteins to the proxi-
Cabanes-Macheteau et al. [36••] reported the first detailed mal endoplasmic reticulum. Alternatively, the plant-specific
analysis of the glycosylation of a plant-produced monoclon- fucosyl transferase [44] or xylosyl transferase, which are
al antibody (plantibody). Both N-glycosylation sites located active in the transgolgi, may be targeted for silencing.
on the heavy-chain of the plantibody are N-glycosylated;
however, the number of glycoforms is higher in the plant Post-transcriptional gene silencing
than in mammalian-expressed antibodies. In addition to Silencing of introduced transgenes has frequently been
high-mannose-type N-glycans, 60% of the oligosaccharides observed in plants, constituting a major commercial prob-
N-linked to the plantibody have β(1,2)-xylose and lem [45•]. Post-transcriptional gene silencing (PTGS) is a
α(1,3)-fucose residues linked to the core Man3GlcNAc2. sequence-specific RNA degradation mechanism that is
widespread in eukaryotic organisms. It is often associated
These oligosaccharides linkages, not found on mammalian with methylation of the transcribed region of the silenced
N-linked glycans, are potentially immunogenic and raise gene and with the accumulation of small RNA molecules
the possibility that plantibodies containing N-linked (21 to 25 nucleotides) homologous to the silenced gene. In
glycans might have limited scope as parenterals or even plants, PTGS can be triggered locally and then spread
when applied topically or orally, particularly in patients with throughout the organism via a mobile signal that can cross
severe food allergies. Food allergens bearing β(1,2)-xylose a graft junction. PTGS has been shown to occur in many
Producing proteins in transgenic plants and animals Larrick and Thomas 413

transgenic dicotyledonous plants and more recently in initial analysis of the data indicates that the plantibody
monocotyledonous plants [46]. significantly reduces the levels of S. mutans. Further
confirmatory trials have been designed to optimize the
Until now, the most efficient strategy to avoid PTGS was to treatment regimen.
carefully design transgene constructs (e.g. eliminating
repeat sequences) and by thorough analysis of transfor- The recent availability of large amounts of sIgA plantibod-
mants at the molecular level [47]. When matrix attachment ies opens up a number of novel therapeutic opportunities
regions (MARs) are positioned on either side of a transgene for disorders of the mucosal immune system. These
their presence usually results in higher and more stable include therapies for intestinal pathogens such as hepatitis
expression in transgenic plants or cell lines, most likely by viruses, Helicobacter pylori, enterotoxigenic Escherichia coli
minimizing gene silencing [48]. The helper-component and cholera, respiratory pathogens (e.g. rhinovirus and
proteinase (HC-Pro) of plant potyviruses suppresses influenza), and genitourinary sexually transmitted diseases
PTGS. Introduction of HC-Pro into plants results in loss of (e.g. herpes simplex virus [3]). SIgA might also be devel-
PTGS, loss of small RNAs, and partial loss of methylation. oped as a method of contraception. A number of other
Grafting experiments indicate that HC-Pro prevents the plantibodies, usually of the IgG class, are currently under
plant from responding to the mobile silencing signal, but development. The most advanced of these, an anti-
does not eliminate its ability to produce or send the signal EPCAM plantibody (co-developed by NeoRx and
[49•]. HC-Pro targets a PTGS maintenance component (as Monsanto) was recently discontinued after phase II trials
opposed to an initiation or signaling component) at a point demonstrated significant gastrointestinal side-effects.
that affects accumulation of small RNAs and methylation of
genomic DNA [50••]. Recent mutagenesis studies are Recombinant bioactive avidin and β-glucuronidase [22,54]
beginning to define the plant genes involved in this inter- are the first recombinant plant-derived proteins to be pro-
esting and important process [51]. duced commercially (made by Prodigene Inc., College
Station, TX) and sold by Sigma Chemical company
Therapeutic advances using plant-produced proteins (St Louis, MO). Two other proteins that will be required in
The most widely studied therapeutic proteins produced in large quantity for nutriceutical use (lactoferrin [55]) or cos-
plants have been monoclonal antibodies for passive meceutical use (collagen [56•]) were recently produced in
immunotherapy and antigens for use in oral vaccines. transgenic plants. Hirudin, a therapeutic anticoagulant, has
Although a large number of useful proteins have been suc- been produced by Sembiosys (Calgary, Canada) using
cessfully expressed in transgenic plants (Table 1) [52•], a oleosin-fusion technology [57], which allows extraction
limited number of therapeutic products have entered the using canola oil bodies.
clinic. Products that have entered clinical trials include two
antibodies, an oral vaccine and pancreatic lipase. The most Edible vaccines [58] produced in transgenic plants have
advanced product is an anti-Streptococcus mutans secretory the potential to revolutionize vaccination, particularly in
IgA (SIgA) plantibody currently in phase II clinical trials for less-developed countries. Numerous vaccine proteins have
the prevention of dental caries. At the present time, plants been produced in plants and demonstrated to be both
offer the only large-scale, commercially viable system for immunogenic and protective against pathogen challenge
production of this unique form of antibody [1]. SIgA is the (see Table 1). Recently, the first human trials were report-
most abundant antibody class produced by the body (>60% ed of plant-produced bacterial [8] and viral [59] oral
of total immunoglobulin) and is secreted onto mucosal sur- vaccines. These demonstrated modest levels of protective
faces to provide local protection from toxins and pathogens. antibodies in serum and stool.
SIgA is comprised of four different protein chains: heavy
and light immunoglobulin chains that form the antigen- Recently, respiratory syncytial virus vaccine [60], canine par-
binding hypervariable region; the J chain that dimerizes two vovirus [61], measles [62], transmissible gastroenteritis virus
IgA molecules (SIgA has four antigen-binding sites); and the (TGEV) [63], and improved hepatitis B virus vaccines have
secretory component that is derived from the polyim- been prepared in plants [6,64]. Wigdorovitz et al., [65] devel-
munoglobulin receptor of mucosal epithelial cells [53]. oped transgenic alfalfa expressing the structural protein VP1
Previously, it was not possible to obtain therapeutic quanti- of foot-and-mouth disease virus. Mice, parenterally immu-
ties of this class of immunoglobulin. The initial clinical nized using leaf extracts or fed freshly harvested leaves from
studies demonstrate that topically applied anti-S. mutans the transgenic plants, developed a virus-specific protective
SIgA plantibody is safe (i.e. no human antimouse antibody immune response. These studies demonstrate the feasibili-
response [HAMA] and no local or systemic toxicity) and pre- ty of this ‘appropriate technology’ for developing countries
vents colonization by S. mutans, the major cause of human where vaccines are urgently needed.
dental caries [2]. Planet Biotechnology Inc. completed
United States Food and Drug Administration (FDA)- Transgenic animals
approved phase I/II confirmatory clinical trials at the School Technological advances using transgenic animals
of Dentistry at the University of California in San Francisco One of the more promising approaches to the large-scale
in late 2000. Details will be published elsewhere; however, production of recombinant proteins has been the secretion
414 Protein technologies and commercial enzymes

of proteins into the milk of transgenic mammals. This has and propagated. Recently, however, there have been
been successfully demonstrated for over two dozen differ- reports of established embryonic stem cells from cattle [69]
ent proteins in either cows, goats, sheep, pigs, rabbits or and goats [70]. A surprising breakthrough was made sever-
mice and appears particularly promising for the production al years ago by Wilmut et al. [71] who showed that a sheep,
of large amounts of monoclonal antibodies [66]. Indeed, Dolly, could be created from the transfer of a nucleus from
the commercial promise for using animals as bioreactors for an adult somatic cell as opposed to an embryonic cell. Since
protein production is being realized through several com- that time a number of different adult cell types have been
panies, including Genzyme Transgenics, Pharming Group, used as nuclear donors for the cloning of sheep, cattle,
PPL Therapeutics and Infigen Inc. Although recombinant goats, pigs and mice. These include tissue fibroblast cells
proteins can be expressed in other tissues, milk has from ears and tails, as well as fibroblast cell lines, tissue
remained the major mode of production due to the large cumulus cells, mammary gland epithelial cells, oviduct,
volume produced by lactating female animals and the ease uterine, skin, muscle, and liver cells) [69,72–75]. The opti-
of collection and purification of the protein product. In mal technology in each case is still being developed and
goats, for example, a lactating female can produce up to includes variables on the timing and method for activation
800 L of milk a year, which can contain around 5 g recom- of the recipient enucleated oocyte, the cell cycle of the
binant protein/L to yield around 4 kg of protein per year. donor nucleus, and the fusion method. Polejaeva et al.
Thus, even a modest herd of transgenic goats can produce [76••] developed a new double nuclear transfer procedure
several hundred kilograms of protein product each year at in pigs using granulosa cells as the nuclear donor; this
a low production cost. In addition to milk, urine has been approach minimizes in vitro activation and increases the
suggested as another feasible route for the production of efficiency of producing viable births. The next step is to
recombinant proteins [67,P1]. Another more recent produce animals that have been genetically modified by
approach is to produce recombinant proteins in transgenic using nuclei from engineered cell lines. Ideally, this would
chicken eggs; high-yield protein can be expressed in eggs, include targeted gene insertion for optimal expression, con-
harvesting is straightforward and production is easy to trolled copy number, and inducible expression of the
scale-up. Studies into this method of protein production introduced gene. McCreath et al. [77••] used gene targeting
have been undertaken by the Avian Initiative, a collabora- in ovine fibroblast cells to introduce the gene encoding
tion between Viragen and the Roslin Institute. human α1-antitrypsin (AAT) and these cells were then
used as nuclear donors. Several sheep were born that
To date, most recombinant proteins produced in transgenic expressed AAT and the milk of one of them expressed AAT
animals have involved the microinjection of a genetic at 650 µg/ml following induced lactation. Unfortunately,
construct the expression of which is driven by a mammary- the majority of the lambs died and showed evidence of a
gland-specific promoter (e.g. for the production of caseins, spectrum of genetic abnormalities, as has been observed
whey acidic protein, lactalbumins and lactoglobulin). with cloned calves [78]. This raises the possibility that
Although successful, this approach is inefficient and time- manipulation of the nucleus may introduce alterations to
consuming. The challenge is to improve the efficiency and reprogramming that impair full development, as found with
speed of producing high-yield protein-expressing founder nuclei that were repeatedly recycled [79••].
animals. One way to quickly determine the activity and sta-
bility of a recombinant protein in milk is to transfect In addition to unknown effects of nuclear transfer on
mammary tissue in vivo using an expression plasmid encod- embryonic development, there is also the question about
ing the protein, as shown with human growth hormone long-term effects on cloned animals after birth. It was sur-
[68••] which was infused through the nipple canal. A prising to discover that Dolly had shortened telomeres of a
similar strategy could also be used to potentially transfect length similar to that of the donor nuclei [80]. As shortened
bladder epithelial cells for expression of proteins in urine. telomeres are a process of aging and are thought to be asso-
However, neither of these approaches would result in the ciated with decreased replicative ability and lifespan, this
production of large amounts of protein. observation raised questions about the feasibility of pro-
ducing cloned animals by nuclear transfer without causing
One very promising approach to increasing the efficiency of major problems, including a shortened life. By contrast,
creating a herd of animal bioreactors with improved recom- additional studies have found that telomerase activity,
binant protein expression is through nuclear transfer which maintains telomere length, is reprogrammed in
technology. Transgenic mice have been produced for some nuclear transferred embryos and is similar to that obtained
years using genetically modified pluripotential embryonic from conventional embryos [81]. Furthermore, the telom-
stem cells that were introduced into the early embryo to ere length in cloned fetuses and calves was the same as in
create a chimeric mouse. Although transfer of nuclei from normal animals even when the donor nuclei from adult
embryonic cells into enucleated oocytes was used success- fibroblasts had shortened telomeres [82••]. In a similar
fully to create cloned animals in larger mammalian species, fashion, Lanza et al. [83] found that nuclei from senescent
these embryonic cells were difficult to genetically modify cells could be rejuvenated upon transfer and were able to
and there was an absence of a cloned embryonic stem cell generate cloned calves with extended telomeres. These
line in which transfectants could be more readily identified latter studies would suggest that normal cloned animals
Producing proteins in transgenic plants and animals Larrick and Thomas 415

can be produced by nuclear transfer from aged adult donor embryos suffer abnormalities and are not viable. When live
cells and that that the age-limiting telomere shortening can births do occur, the next challenge is to identify animals that
be reversed. The differences between these observations produce high levels of protein and can serve as founders for
and those reported by Shiels et al. [80] remain to be a herd. This selection procedure has a relatively low success
resolved but could relate to the species and/or donor cells rate, particularly with animals produced using microinjec-
or the technology used to optimize each system. tion technology. Theoretically, the use of nuclear transfer
could improve this situation as all animals are derived from
Therapeutic advances using proteins produced in the same nucleus and the animals are not chimeric. This
animal bioreactors approach should also permit greater stability and retention
The expression of proteins in milk offers several uses: to of the introduced gene in subsequent generations. Using
produce large amounts of therapeutics for human or veteri- gene targeting it should be possible to design optimal
nary use; to improve the health of dairy livestock; and to insertion points in the genome for expression of the intro-
produce large amounts of proteins used in commercial duced gene, which could remove some of the expression
processes or in drug formulation, such as human serum variability that results from more random insertion.
albumin. Although an increasing number of proteins are
being produced in milk, most are in preclinical develop- The second issue facing protein production in recombi-
ment and few are yet in clinical testing. Pharming Group nant animals is the speed to commercial product. With
and Genzyme are developing recombinant human microinjection technology, to produce large amounts of
α-glucosidase to treat infants with Pompe’s disease, which product the founders must first be identified and then
results from a genetic deficiency in this enzyme. Enzyme used to breed and establish the herd. With cows, for exam-
produced in rabbits milk was well-tolerated and showed ple, the age to sexual maturity is around 15 months and
clinical benefit in treated patients [84]. Pharming Group each cow has a single offspring. In females natural lactation
and Baxter Healthcare Corporation have also recently initi- also occurs at around three years of age. It is clear that to
ated clinical testing with a rabbit-milk-derived recombinant produce a sufficient herd for commercial production takes
human C1 inhibitor to treat patients with hereditary a number of years. Again, this could be greatly expedited
angioedema who exhibit C1 inhibitor deficiency. Pharming using nuclear transfer; once a female founder is identified,
Group has also just completed a phase I clinical study with cells from that animal can donate nuclei to produce a herd
recombinant human lactoferrin — the protein was found to in one generation.
be safe and well tolerated. Lactoferrin will be tested initial-
ly for heparin neutralization in coronary artery angioplasty Another issue that needs to be considered with animal
or bypass surgery. Recently, human lactoferrin was also production of recombinant proteins is that of infectious
found to have potent antibacterial activity in animal models diseases. The potential for products to contain prions has
using antibiotic-resistant Staphylococci, which could broad- been a concern for some time, and most companies have
en its clinical use [85]. Genzyme Transgenics and Genzyme designed a process and testing to assure that their products
General have produced antithrombin III in goats milk; the are prion-free. A current problem is the occurrence of
protein is currently in phase III clinical trials to prevent sudden epidemics that can devastate livestock herds, such
blood clotting during cardiac surgery in heparin-resistant as foot-and-mouth disease. There is a necessity to place
patients [86]. Goat herds are also being developed by herds in different regions of the world to avoid such
Genzyme Transgenics for the large-scale production of the catastrophes, but even this cannot avoid potential loss of a
tumor necrosis inhibitory monoclonal antibody, Remicade. manufacturing herd. For example, the foot-and-mouth
Remicade is marketed by Centocor for the treatment of disease outbreak in England quickly spread to other parts
inflammatory conditions, including Crohn’s disease and of Europe. Foot and mouth is also prevalent in South
rheumatoid arthritis. America and the Middle East. One can control as much as
possible to ensure a safe and healthy herd of transgenic
Another use for the expression of recombinant proteins in animals, but there are unknown risks that can be
milk is to prevent mastitis caused by Staphylococcus in catastrophic. This concern may stimulate even greater
dairy cattle. For example, Kerr and colleagues [87••] efforts to develop animals resistant to disease, as pointed
showed that expression of recombinant lysostaphin in the out above for lysostaphin, and to produce new effective
milk of mice prevented Staphylococcus aureus infection. vaccines to ward off known pathogens.

Issues regarding the production of proteins in animals Finally, the therapeutic proteins produced in transgenic
The technologies discussed above go some way towards animals undergo post-translational processing characteris-
addressing the two big issues facing animal production of tic of that animal, although the protein itself is of human
recombinant proteins: efficiency and the speed with which sequence. Because carbohydrates in recombinant glyco-
a commercial product can be produced. The current meth- proteins, in particular, are somewhat different from those
ods for producing transgenic animals lead to live births at a of human origin, there is still a question about whether or
low rate and the success rate is generally below 10%. Even not this will have adverse effects, such as eliciting an
with nuclear transfer, the success rate is low and many immune response or conferring altered biodistribution or
416 Protein technologies and commercial enzymes

retention. Although only few animal-produced protein 13. Ma SW, Zhao DL, Yin ZQ, Mukherjee R, Singh B, Qin HY, Stiller CR,
Jevnikar AM: Transgenic plants expressing autoantigens fed to
drugs have yet been administered to humans, there does mice to induce oral immune tolerance. Nat Med 1997, 3:793-796.
not appear to be any issue with respect to the circulating 14. Dalsgaard K, Uttenthal A, Jones TD, Xu F, Merryweather A,
half-life or production of antibodies. Hamilton WD, Langeveld JP, Boshuizen RS, Kamstrup S,
Lomonossoff GP et al.: Plant-derived vaccine protects target
animals against a viral disease. Nat Biotechnol 1997 15:248-252.
Conclusions
15. Austin S, Bingham ET, Koegel RG, Mathews DE, Shahan MN,
In summary, the future production of recombinant proteins Straub RJ, Burgess RR: An overview of a feasibility study for the
in plants or in the milk of animals looks promising. The production of industrial enzymes in transgenic alfalfa. Annu NY
Acad Sci 1994, 721:235-244.
number of applications will increase as more therapeutic
proteins are required in quantities that cannot be attained 16. Khoudi H, Laberge S, Ferullo JM, Bazin R, Darveau A, Castonguay Y,
• Allard G, Lemieux R, Vezina LP: Production of a diagnostic
economically in cell culture. With the advent of nuclear monoclonal antibody in perennial alfalfa plants. Biotechnol Bioeng
transfer technology, optimized production of recombinant 1999, 20:135-143.
First demonstration of alfalfa production of a transgenic antibody.
proteins in milk should become even more efficient and
17. Kusnadi A, Nikolov R, Zivko L, Howard J A: Production of
inexpensive. In plants, efforts to modify glycosylation and recombinant proteins in transgenic plants: practical
control post-transcriptional gene silencing will enhance considerations. Biotechnol Bioeng 1997, 56:473-484.
the value of this important technology. An increasing 18. Kusnadi A, Evangelista R, Hood E, Howard J, Nikolov Z: Processing
number of transgenic plant- and animal-derived proteins of transgenic corn seed and its effect on the recovery of
recombinant β-glucuronidase. Biotechnol Bioeng 1998, 60:44-52.
are entering clinical testing. The initial success of these
19. Kusnadi A, Hood E, Witcher D, Howard J, Nikolov Z: Production and
development programs suggests an important role for cost- purification of two recombinant proteins from transgenic corn.
effective and large-scale production technologies. Biotechnol Prog 1998, 14:149-155.
20. Krebbers E: Prospects and progress in the production of foreign
References and recommended reading proteins and peptides in transgenic plants. In Plant Protein
Papers of particular interest, published within the annual period of review, Engineering. Edited by Shewry PR, Gutteridge S. Cambridge
have been highlighted as: University Press; 1992:315-325.

• of special interest 21. Whitelam GC, Cockburn W, Owen MRL: Antibody production in
transgenic plants. Biochem Soc Trans 1994, 22:940-943.
•• of outstanding interest
22. Hood EE, Kusnadi A, Nikolov Z, Howard JA: Molecular farming of
1. Ma JK, Hiatt A, Hein M, Vine ND, Wang F, Stabila P,
industrial proteins from transgenic maize. Adv Exp Med Biol 1999,
van Dolleweerd C, Mostov K, Lehner T: Generation and assembly of
464:127-147.
secretory antibodies in plants. Science 1995, 268:716-719.
23. Larrick JW, Yu L, Chen J, Jaiswal S, Wycoff K: Production of
2. Ma J, Hikmat B, Wycoff K, Vine N, Chargelegue D, Yu L, Hein M,
antibodies in transgenic plants. Res Immunol 1998, 149:603-608.
Lehner T: Characterization of a recombinant plant monoclonal
secretory antibody and preventive immunotherapy in humans. Nat 24. Russell DA: Feasibility of antibody production in plants for human
Med 1998, 4:601-606. therapeutic use. Curr Top Microbiol Immunol 1999, 236:119-137.
3. Zeitlin L, Olmsted SS, Moench TR, Co MS, Martinell BJ, Paradkar VM, 25. Hood EE, Jilka JM: Plant-based production of xenogenic proteins.
Russell DR, Queen C, Cone RA, Whaley KJ: A humanized monoclonal Curr Opin Biotechnol 1999, 10:382-386.
antibody produced in transgenic plants for immunoprotection of the
vagina against genital herpes. Nat Biotechnol 1998, 16:1361-1364. 26. Fiedler U, Conrad U: High-level production and long-term storage
of engineered antibodies in transgenic tobacco seeds. BioTechnol
4. Mason HS, Lam DM, Arntzen CJ: Expression of hepatitis B surface 1995, 13:1090-1093.
antigen in transgenic plants. Proc Natl Acad Sci USA 1992,
89:11745-11749. 27. Horvath H, Huang J, Wong O, Kohl E, Okita T, Kannangara LG,
• von Wettstein D: The production of recombinant proteins in
5. Thanavala Y, Wang Y-F, Lyons P, Mason HS, Arntzen C: transgenic barley grains. Proc Natl Acad Sci USA 2000,
Immunogenicity of transgenic plant-derived hepatitis B surface 97:1914-1919.
antigen. Proc Natl Acad Sci USA 1995, 92:3358-3361. An early paper demonstrating transgenic production using barley.
6. Richter LJ, Thanavala Y, Arntzen CJ, Mason HS: Production of 28. Zhang P, Potrykus I, Puonti-Kaerlas J. Efficient production of
hepatitis B surface antigen in transgenic plants for oral • transgenic cassava using negative and positive selection.
immunization. Nat Biotechnol 2000 18:1167-1171. Transgenic Res 2000, 9:405-415.
Cassava may be a useful ‘bioreactor’ in the tropics.
7. Mason HS, Ball JM, Shi JJ, Jiang X, Estes MK, Arntzen CJ: Expression of
Norwalk virus capsid protein in transgenic tobacco and its oral 29. Schenk PM, Sagi L, Remans T, Dietzgen RG, Bernard MJ,
immunogenicity in mice. Proc Natl Acad Sci USA 1996, 93:5335-5340. Graham MW, Manners JM: A promoter from sugarcane bacilliform
badnavirus drives transgene expression in banana and other
8. Tacket CO, Mason HS, Losonsky G, Clements JD, Levine MM, monocot and dicot plants. Plant Mol Biol 1999, 39:1221-1230.
Arntzen CJ: Immunogenicity in humans of a recombinant bacterial
antigen delivered in a transgenic potato. Nat Med 1998, 4:607-609. 30. Staub JM, Garcia B, Graves J, Hajdukiewicz PT, Hunter P, Nehra N,
•• Paradkar V, Schlittler M, Carroll JA, Spatola L et al.: High-yield
9. Haq TA, Mason HS, Clements JD, Arntzen CJ: Oral immunization production of a human therapeutic protein in tobacco
with a recombinant bacterial antigen produced in transgenic chloroplasts. Nat Biotechnol 2000, 18:330-338.
plants. Science 1995, 268:714-716. Demonstration by the Monsanto/Agracetus/Calgene group(s) of the utility of
using chloroplasts for high-level expression of transgenic proteins.
10. Mason HS, Haq TA, Clements JD, Arntzen CJ: Edible vaccine protects
mice against Escherichia coli heat-labile enterotoxin (LT): potatoes 31. Henriques L, Daniell H: Expression of cholera toxin B subunit
expressing a synthetic LT-B gene. Vaccine 1998, 16:1336-1343. oligomers in transgenic tobacco chloroplasts. Proc Nat Acad Sci
USA 2001, in press.
11. Arakawa T, Chong DK, Merritt JL, Langridge WH: Expression of
cholera toxin B subunit oligomers in transgenic plants. Transgenic 32. De Cosa B, Moar W, Lee S-B, Miller M, Daniell H: Overexpression of
Res 1997, 6:403-413. the Bt cry2Aa2 operon in chloroplasts leads to formation of
insecticidal crystals. Nat Biotechnol 2001, 19:71-74.
12. Arakawa T, Chong DK, Langridge WH: Efficacy of a food plant-
based oral cholera toxin B subunit vaccine. Nat Biotechnol 1998, 33. MacFarlane SA, Popovich AH: Efficient expression of foreign
16:292-297. proteins in roots from tobravirus vectors. Virology 2000, 267:29-35.
Producing proteins in transgenic plants and animals Larrick and Thomas 417

34. Toth RL, Chapman S, Carr F, Santa Cruz S: A novel strategy for the 53. Mostov KE, Altschuler Y, Chapin SJ, Enrich C, Low SH, Luton F,
expression of foreign genes from plant virus vectors. FEBS Lett Richman-Eisenstat J, Singer KL, Tang K, Weimbs T: Regulation of
2001, 489:215-219. protein traffic in polarized epithelial cells: the polymeric
immunoglobulin receptor model. Cold Spring Harb Symp Quant
35. Petolino JF, Young S, Hopkins N, Sukhapinda K, Woosley A, Hayes C, Biol 1995, 60:775-781.
Pelcher L. Expression of murine adenosine deaminase (ADA) in
transgenic maize. Transgenic Res 2000, 9:1-9. 54. Hood E, Witcher D, Maddock S, Meyer T, Baszczynski C, Bailey M,
Flynn P, Register J, Marshall L, Bond D et al.: Commercial production
36. Cabanes-Macheteau M, Fitchette-Laine AC, Loutelier-Bourhis C, of avidin from transgenic maize: characterization of transformant,
•• Lange C, Vine ND, Ma JK, Lerouge P, Faye L: N-Glycosylation of a production, processing, extraction and purification. Mol Breed
mouse IgG expressed in transgenic tobacco plants. Glycobiology 1997, 3:291-306.
1999, 9:365-372.
The first in-depth study of glycosylation of a plantibody. 55. Chong DK, Langridge WH: Expression of full-length bioactive
antimicrobial human lactoferrin in potato plants. Transgenic Res
37. Fotisch K, Altmann F, Haustein D, Vieths S: Involvement of 2000, 9:71-78.
carbohydrate epitopes in the IgE response of celery-allergic
patients. Int Arch Allergy Immunol 1999, 120:30-42. 56. Ruggiero F, Exposito JY, Bournat P, Gruber V, Perret S, Comte J,
• Olagnier B, Garrone R, Theisen M: Triple helix assembly and
38. Garcia-Casado G, Sanchez-Monge R, Chrispeels MJ, Armentia A, processing of human collagen produced in transgenic tobacco
Salcedo G, Gomez L: Role of complex asparagine-linked glycans
plants. FEBS Lett 2000, 469:132-136.
in the allergenicity of plant glycoproteins. Glycobiology 1996,
Production of a high molecular weight protein with potential for both cos-
4:471-477.
meceutical and pharmaceutical use.
39. van Ree R, Aalberse RC: Specific IgE without clinical allergy.
57. Rooijen V, Moloney M: Structural requirements of oleosin domains
J Allergy Clin Immunol 1999, 103:1000-1001.
for subcellular targeting to the oilbody. Plant Physio/ 1995,
40. Mari A, Iacovacci P, Afferni C, Barletta B, Tinghino R, Di Felice G, 109:1353-1361.
Pini C: Specific IgE to cross-reactive carbohydrate determinants
58. Fooks AR: Development of oral vaccines for human use. Curr Opin
strongly affects the in vitro diagnosis of allergic diseases. J Allergy
Mol Ther 2000, 2:80-86.
Clin Immunol 1999, 103:1005-1011.
41. van der Veen MJ, van Ree R, Aalberse RC, Akkerdaas J, 59. Tacket CO, Mason HS, Losonsky G, Estes MK, Levine MM, Arntzen CJ:
Koppelman SJ, Jansen HM, van der Zee JS: Poor biologic activity of Human immune responses to a novel Norwalk virus vaccine
cross-reactive IgE directed to carbohydrate determinants of delivered in transgenic potatoes. J Infect Dis 2000, 182:302-305.
glycoproteins. J Allergy Clin Immunol 1997, 100:327-334. 60. Belanger H, Fleysh N, Cox S, Bartman G, Deka D, Trudel M,
42. Bakker H, Bardor M, Molthoff JW, Gomord VV, Elbers II, Stevens LH, Koprowski H, Yusibov V: Human respiratory syncytial virus vaccine
Jordi W, Lommen A, Faye L, Lerouge P, Bosch D: Galactose- antigen produced in plants. FASEB J 2000, 14:2323-2328.
extended glycans of antibodies produced by transgenic plants. 61. Gil F, Brun A, Wigdorovitz A, Catala R, Martinez-Torrecuadrada JL, Casal I,
Proc Natl Acad Sci USA 2001, 98:2899-2904. Salinas J, Borca MV, Escribano JM: High-yield expression of a viral
43. Wandelt CI, Khan MRI, Craig S, Schroeder HE, Spencer D, peptide vaccine in transgenic plants. FEBS Lett 2001, 488:13-27.
Higgins TJV: Vicilin with carboxy-terminal KDEL is retained in the 62. Huang Z, Dry II, Webster D, Strugnell R, Wesselingh S: Plant-derived
endosplasmic reticulum and accumulates to high levels in leaves measles virus hemagglutinin protein induces neutralizing
of transgenic plants. Plant J 1992, 2:181-192. antibodies in mice. Vaccine 2001, 19:2163-2171.
44. Leiter H, Mucha J, Staudacher E, Grimm R, Glossl J, Altmann F: 63. Tuboly T, Yu W, Bailey A, Degrandis S, Du S, Erickson L, Nagy E:
Purification, cDNA cloning, and expression of GDP-L-Fuc:Asn- Immunogenicity of porcine transmissible gastroenteritis virus
linked GlcNAcα α1,3-fucosyltransferase from mung beans. J Biol spike protein expressed in plants. Vaccine 2000, 18:2023-2028.
Chem 1999, 274:21830-21839.
64. Kapusta J, Modelska A, Figlerowicz M, Pniewski T, Letellier M,
45. Vaucheret H, Fagard M: Transcriptional gene silencing in plants: Lisowa O, Yusibov V, Koprowski H, Plucienniczak A, Legocki AB: A
• targets, inducers and regulators. Trends Genet 2001, 17:29-35. plant-derived edible vaccine against hepatitis B virus. FASEB J
Most recent review of gene silencing in plants. 1999, 13:1796-1799.
46. Kanno T, Naito S, Shimamoto K: Post-transcriptional gene silencing 65. Wigdorovitz A, Carrillo C, Dus Santos MJ, Trono K, Peralta A,
in cultured rice cells. Plant Cell Physiol 2000, 41:321-326. Gomez MC, Rios RD, Franzone PM, Sadir AM, Escribano JM,
47. de Wilde C, Van Houdt H, de Buck S, Angenon G, de Jaeger G, Borca MV: Induction of a protective antibody response to foot and
Depicker A: Plants as bioreactors for protein production: avoiding the mouth disease virus in mice following oral or parenteral
problem of transgene silencing. Plant Mol Biol 2000, 43:347-359. immunization with alfalfa transgenic plants expressing the viral
structural protein VP1. Virology 1999, 255:347-353.
48. Allen GC, Spiker S, Thompson WF: Use of matrix attachment
regions (MARs) to minimize transgene silencing. Plant Mol Biol 66. Pollock DP, Kutzko JP, Birck-Wilson E, Williams JL, Echelard Y,
2000, 43:361-376. Meade HM: Transgenic milk as a method for the production of
recombinant antibodies. J Immunol Methods 1999, 231:147-157.
49. Mallory AC, Ely L, Smith TH, Marathe R, Anandalakshmi R, Fagard M,
• Vaucheret H, Pruss G, Bowman L, Vance VB: HC-Pro suppression of 67. Meade H, Ziomek C: Urine as a substitute for milk? Nat Biotechnol
transgene silencing eliminates the small RNAs but not transgene 1998, 16:21-22.
methylation or the mobile signal. Plant Cell 2001, 13:571-583.
68. Hens JR, Amstutz MD, Schanbacher FL, Mather IH: Introduction of
Grafting experiments indicate that HC-Pro prevents the plant from respond-
ing to the mobile silencing signal but does not eliminate its ability to produce •• the human growth hormone gene into the guinea pig mammary
or send the signal. gland by in vivo transfection promotes sustained expression of
human growth hormone in the milk throughout lactation. Biochim
50. Llave C, Kasschau KD, Carrington JC: Virus-encoded suppressor of Biophys Acta 2000, 1523:161-171.
•• posttranscriptional gene silencing targets a maintenance step in Rapid expression of recombinant proteins in milk is important to ascertain its
the silencing pathway. Proc Natl Acad Sci USA 2000, stability and qualitative aspects before embarking on a costly campaign to
97:13401-13406. produce transgenic animals. This article illustrates one technique by which
An interesting and important paper investigating the mechanism of post-tran- this can be accomplished through the transfection of mammary tissue with a
scriptional gene silencing. nonviral expression vector to produce adequate levels of recombinant pro-
tein in milk suitable for analysis.
51. Mittelsten Scheid O, Afsar K, Paszkowski J: Release of epigenetic
gene silencing by trans-acting mutations in Arabidopsis. Proc Natl 69. Shiga K, Fujita T, Hirose K, Sasae Y, Nagai T: Production of calves
Acad Sci USA 1998, 95:632-636. by transfer of nuclei from cultured somatic cells obtained from
Japanese black bulls. Theriogenology 1999, 52:527-535.
52. Daniell H, Streatfield SJ, Wycoff K. Medical molecular farming:
• production of antibodies, biopharmaceuticals and edible vaccines 70. Kuhholzer B, Baguisi A, Overstrom EW: Long-term culture and
in plants. Trends Plant Sci 2001, 6:219-226. characterization of goat primordial germ cells. Theriogenology
An excellent review of molecular pharming. 2000, 53:1071-1079.
418 Protein technologies and commercial enzymes

71. Wilmut I, Schnieke AE, McWhir J, Kind AJ, Campbell KH: Viable 82. Betts D, Bordignon V, Hill J, Winger Q, Westhusin M, Smith L,
offspring derived from fetal and adult mammalian cells. Nature •• King W: Reprogramming of telomerase activity and rebuilding of
1997, 385:810-813. telomere length in cloned cattle. Proc Natl Acad Sci USA 2001,
98:1077-1082.
72. Kishi M, Itagaki Y, Takakura R, Imamura M, Sudo T, Yoshinari M, The potentially shortened telomeres in offspring derived senescent adult cell
Tanimoto M, Yasue H, Kashima N: Nuclear transfer in cattle using nuclear donors, as shown with Dolly, raised a significant problem in the long-
colostrum-derived mammary gland epithelial cells and ear- term viability of cloned animals. This article shows that telomerase activity is
derived fibroblast cells. Theriogenology 2000, 54:675-684. reprogrammed upon transfer of nuclei with shortened telomeres into oocytes
and that cloned embryos and newborn calves had normal telomere lengths.
73. Kato Y, Tani T, Tsunoda Y: Cloning of calves from various somatic It will be important to discover the mechanism for reprogramming of telom-
cell types of male and female adult, newborn and fetal cows. erase such that lengthening of shortened telomeres is reproducible.
J Reprod Fertil 2000, 120:231-237.
83. Lanza RP, Cibelli JB, Blackwell C, Cristofalo VJ, Francis MK,
74. Betthauser J, Forsberg E, Augenstein M, Childs L, Eilertsen K, Enos J, Baerlocher GM, Mak J, Schertzer M, Chavez EA, Sawyer N et al.:
Forsythe T, Golueke P, Jurgella G, Koppang R et al.: Production of Extension of cell life-span and telomere length in animals cloned
cloned pigs from in vitro systems. Nat Biotechnol 2000, from senescent somatic cells. Science 2000, 288:665-669.
18:1055-1059.
84. Van den Hout H, Reuser AJ, Vulto AG, Loonen MC,
75. Ogura A, Inoue K, Takano K, Wakayama T, Yanagimachi R: Birth of Cromme-Dijkhuis A, Van der Ploeg AT: Recombinant human
mice after nuclear transfer by electrofusion using tail tip cells. Mol α-glucosidase from rabbit milk in Pompe patients. Lancet 2000,
Reprod Dev 2000, 57:55-59. 356:397-398.
76. Polejaeva IA, Chen SH, Vaught TD, Page RL, Mullins J, Ball S, Dai Y, 85. Nibbering PH, Ravensbergen E, Welling MM, van Berkel LA,
•• Boone J, Walker S, Ayares DL et al.: Cloned pigs produced by van Berkel PH, Pauwels EK, Nuijens JH: Human lactoferrin and
nuclear transfer from adult somatic cells. Nature 2000, 407:86-90. peptides derived from its N terminus are highly effective against
For some reason pigs have been more difficult to clone than cows, sheep or infections with antibiotic-resistant bacteria. Infect Immun 2001,
goats. In this article, a novel technique using a double nuclear transfer result- 69:1469-1476.
ed in viable piglets. This is a procedure that relies on in vivo activation and
minimizes in vitro manipulation. It will be interesting to determine if this pro- 86. Yeung PK: Technology evaluation: transgenic antithrombin III
cedure reduces the abnormalities in other species arising from nuclear trans- (rhAT-III), Genzyme Transgenics. Curr Opin Mol Ther
fer into oocytes activated in vitro. 2000, 2:336-339.

77. McCreath KJ, Howcroft J, Campbell KH, Colman A, Schnieke AE, 87. Kerr DE, Plaut K, Bramley AJ, Williamson CM, Lax AJ, Moore K,
•• Kind AJ: Production of gene-targeted sheep by nuclear transfer •• Wells KD, Wall RJ: Lysostaphin expression in mammary glands
from culture somatic cell. Nature 2000, 405:1066-1069. confers protection against staphylococcal infection in transgenic
One of the promises of nuclear transfer is the rapid scale-up of animals mice. Nat Biotechnol 2001, 19:66-70.
One of the uses for transgenic animals is to improve the health of dairy animals.
reproducibly expressing the recombinant protein of interest. This article is
This article demonstrates the feasibility of conferring resistance to mastitis
the first demonstrating the generation of cloned sheep that express the
through expression of a recombinant antibacterial protein. It will be important
recombinant protein, human α1-antitrypsin, using targeted gene insertion.
to repeat these studies in dairy animals and to determine if other bioactive
78. Hill JR, Roussel AJ, Cibelli JB, Edwards JF, Hooper NL, Miller MW, recombinant proteins can be produced concurrently with lysostaphin.
Thompson JA, Looney CR, Westhusin ME, Robl JM, Stice SL: Clinical 88. Stoger E, Vaquero C, Torres E, Sack M, Nicholson L, Drossard J,
and pathologic features of cloned transgenic calves and fetuses Williams S, Keen D, Perrin Y, Christou P, Fischer R: Cereal crops as
(13 case studies). Theriogenology 1999, 51:1451-1465. viable production and storage systems for pharmaceutical scFv
79. Peura TT, Lane MW, Lewis IM, Trounson AO: Development of bovine antibodies. Plant Mol Biol 2000 42:583-590.
•• embryo-derived clones after increasing rounds of nuclear 89. McCormick AA, Kumagai MH, Hanley K, Turpen TH, Hakim I, Grill LK,
recycling. Mol Reprod Dev 2001, 58:384-389. Tuse D, Levy S, Levy R: Rapid production of specific vaccines for
One major problem with cloning has been the high incidence of abnormali- lymphoma by expression of the tumor-derived single-chain Fv
ties occurring in the cloned embryo or after birth. In this article the amount epitopes in tobacco plants. Proc Natl Acad Sci USA 1999
of in vitro nuclear manipulation was shown to have a significant effect on 96:703-708.
embryonic development. This points out the need to understand the mecha-
nisms of genetic reprogramming and how this is influenced by different 90. Modelska A, Dietzschold B, Sleysh N, Fu Z, Steplewski K, Hooper D,
manipulations and methodologies. Koprowski H, Yusibov V: Immunization against rabies with plant-
derived antigen. Proc Natl Acad Sci USA 1998, 96:2481-2485.
80. Shiels PG, Kind AJ, Campbell KH, Waddington D, Wilmut I,
Colman A, Schnieke AE: Analysis of telomere lengths in cloned
sheep. Nature 1999, 399:316-317. Patents
81. Xu J, Yang X: Telomerase activity in early bovine embryos derived P1. Lindsay S, Mulroy R, Semeniuk D: Expression of secreted human
from parthenogenetic activation and nuclear transfer. Biol Reprod α-fetoprotein in transgenic animals. Patent Number WO040693A2.
2001, 64:770-774. Issued July 13, 2000.

You might also like