Professional Documents
Culture Documents
Warning!
The installation of hard drives must be performed by
qualified service personnel, using anti-static precautions.
You can install one 3.5-inch ATA hard drive in the
recorder. The recorder will:
? Automatically detect and format a new hard drive.
? Automatically detect and reuse a previously formatted
hard drive.
3204 DVR
To install a hard drive in a recorder
The 3204 DVR is a compact digital video recorder (DVR) 1 Using a Phillips screwdriver, remove two screws
that lets you record and monitor continuous or event- from the lower front left and right corners of
driven audio and video from cameras, microphones, and the recorder.
other connected devices. Key features include: 2 Open the hinged recorder lid.
3 Loosen the four nylon thumbscrews that secure
? A customized Linux operating system that starts from
the hard drive brackets to the recorder lid.
a protected flash memory system.
? A hard drive management system that ensures reliable
4 Slide each bracket until the nylon thumbscrews fit
hard drive operation and early detection of hard through the bracket key slots, freeing the brackets
drive faults. from the recorder lid.
? An internal battery backup system that ensures 5 Secure a bracket to each side of the hard drive
continuous operation or systematic shutdown using two screws.
sequences during power disturbances. 6 Place the hard drive and bracket assembly on the
recorder lid, then tighten the nylon thumbscrews.
Recorder Setup Note: You must mount the hard drive on the recorder
This quick start guide provides basic steps for setting up a lid so that the hard drive connectors point to the left
3204 DVR. The recorder setup tasks include: side of the recorder.
7 Connect the power cable and IDE ribbon cable to
? Installing a hard drive
the hard drive.
? Mounting the recorder
8 Close the recorder lid and replace the screws.
? Powering the recorder
? Connecting to the recorder Recorder Lid
? Configuring the recorder Nylon Thumbscrew
Important
Power Cable
The recorder setup tasks in this quick start guide are in an
abbreviated format. IDE Cable
You can use the 3204 DVR in desk-mount or wall-mount To power on the recorder
applications. Since the recorder is shipped with rubber ? Plug the 12 volts DC input cord into the recorder.
feet installed, no installation modifications are required
for desk-mount applications. To wall-mount the To power off the recorder
recorder, use the following installation procedure: ? Unplug the 12 volts DC input cord from the recorder.
Mounting
Bracket
Bracket
Screw Power
Video Output USB
Ground Port
Stud Provisioning Port
Center
© 2007. March Networks Corporation. All rights reserved. CD-19187 Rev. 1.0. Information in this
document is subject to change without notice. MARCH NETWORKS and the MARCH NETWORKS
logo are trademarks of March Networks Corporation. All other trademarks are the property of their
respective owners. Printed in Canada.