Timing decision
drill hole
v
Ruler or etc
Misconnection prevention drill hol1. Compression upper dead center setting of No.1 cylinder
(1) Turn the crankshaft counterclockwise when viewed from
& Fors the flywheel. Set the timing mark in the flywheel housing
inspection window to "1".
°o
Fiywhoo! —
& (2) Remove the inspection window plug in the bearing holder
case of the supply pump. Tighten the guide bolt (9069-
08180) very gently and make sure that the bolt seating
comes in close contact with the bearing holder.
f A\CAUTION * Ifitis raised, there must be contact other
HRT than the stopper key for the coupling flange.
Do not tighten hard.
4 °
Flywheel housing oJv
e}
a