Professional Documents
Culture Documents
Analysis of Simple Stress
Analysis of Simple Stress
MACHINE
DESIGN 1
ENGR. LOUIE A. LARIOSA
FACULTY – ME DEPARTMENT
CTU – MAIN CAMPUS
CONTENTS
1. Analysis of Simple Stresses
4. Shaft design
9. Gears
ME-PC 321
MACHINE
DESIGN 1
ANALYSIS OF SIMPLE
STRESS
ANALYSIS OF SIMPLE
STRESS
ANALYSIS OF SIMPLE
STRESS
Tensile Stress: the force per unit area which is perpendicular to the
surface that produces stretching by the application of pulling forces.
Compressive Stress: is the stress state when the material is compact.
Bearing Stress: the surface pressure acting on a machine member as a result of
applied load divided bearing area.
Bending Stress: a compressive or tensile longitudinal stress developed in a machine
member as a result of curvature by an external load
Direct Shear Stress: is a type of stress when a force applied produces a sliding
failure of a material along a plane that is parallel to the direction of the applied force.
Torsional Stress: the shear stress on a transverse cross section resulting when one
end of a machine member is twisted in one direction.
STRESS
Normal Shear