This document summarizes the specifications of a 12W solar LED street light luminary that uses a 12.8V 30Ah LiFePO4 battery pack and 12W monocrystalline or polycrystalline solar panel. It provides 1600 lumens of light using Osram or Seoul LED chips and has an IP66 waterproof rating. The light is controlled by an MPPT charge controller to charge the battery from dusk to dawn and power the LEDs at different levels throughout the night.
This document summarizes the specifications of a 12W solar LED street light luminary that uses a 12.8V 30Ah LiFePO4 battery pack and 12W monocrystalline or polycrystalline solar panel. It provides 1600 lumens of light using Osram or Seoul LED chips and has an IP66 waterproof rating. The light is controlled by an MPPT charge controller to charge the battery from dusk to dawn and power the LEDs at different levels throughout the night.
This document summarizes the specifications of a 12W solar LED street light luminary that uses a 12.8V 30Ah LiFePO4 battery pack and 12W monocrystalline or polycrystalline solar panel. It provides 1600 lumens of light using Osram or Seoul LED chips and has an IP66 waterproof rating. The light is controlled by an MPPT charge controller to charge the battery from dusk to dawn and power the LEDs at different levels throughout the night.
Light Source 12watt Light Emitting Diode Supported PV module 75wp mono-poly crystalline PV module Supported Battery 12.8V 30ah LiFePO4 battery pack LED chip used Osram Oslon Square / Seoul Z5M2 Total Lumineous Flux 1600 Lumen LED color temperature 5500K - 6500K Color Redering Index >70 Electronic Efficiency MPPT charge controller efficiency: > 95% LED driver efficiency : > 90% Duty Cycle First four hour: 12wp 100% light Rest: 6wp 50% light(Optional motion sensor) PIR sensor(optional) 12 meter, 102*92 degree working range LED external optics 145 x 90 degree street-light lens IP waterproof protection IP66 Charge controller methodology MPPT three stage battery charge monitoring algorithm MPPT software methodology Perturb and Observe / Hill-climbing Maximum charging current 6.0 amp Protections o Short circuit protection o Battery over charge protection o Battery Deep discharge protection o PV reverse voltage polarity protection o Battery reverse voltage polarity protection Solar panel Dusk to Dawn operation NTTV (Night Time Threshold Voltage):4.0 volt DTTV (Day Time Threshold Voltage):6.0 volt Battery low, load disconnect voltage 11.2 volt Battery full, load reconnect voltage 13.0 volt Battery constant voltage set-point 14.7 volt LED indication Green off: Battery not charging PV low Green on: Battery charging Green flashing: Battery full Red off: Battery not discharged Red on: Battery discharged, load disconnect Ideal current consumption Less than 10 ma Overall dimension 255mm x 90mm x 60mm Overall Weight 1 kg