Time: Three Hours
etpztiwww.kuontine.in
BT-1/DX: 8019
ME-105-E: Engineering Graphics and Design
Masionam Masks : 100
NNote:- There are four Units. Atemp at eat ONE question fom exch nit
Qa.
22
‘Atemtonly FIVE questions ata
UNITI
Construct a vernier scale to read meters, decimeters and.
centimeters and long enough to measure upto 4m. RLF,
of the scale is 1/20. Mark on your scale a distance of
228m, 20
Point A is 20 mm above HP and 30 mm in front of VP.
Point B is the HP and 40 mm behind the VP. The
distance between theie projectors is SOmm. Draw the
projections of the points. Also draw straight lines
Joining their top and front views, 20
http:tivww.knonline.in
Qs.
Qs
26.
etpztiwww.kuontine.in
UNtrar
‘A line DC 80 men long is inclined at an angle of 30° to
LHP and 45° to VP. The point C is 20 mm above HP and
30 mm in front of VP. Draw the projections of the
straight line. 20
A square lamina ABCD, of 30 mm side, is
perpendicular to VP and inclined to HP at 45" It rests on
one of its side (say BC) in HP. Draw its projections and
positions of traces. The comer point C is 12 mm in
Front of VP. 20
NIP
A hexagonal pyramid, sides of base 25 mm and height
‘30 mun rests with its base on HP such that one of the
edges of the base is inclined at 20" to VP. Draw the top
and front views of the pyramid, 20
‘A right regular square prism, 30 mm base edge and 60
3 Fess on its base on HP such that its vertical
faces are equally inclined to VP. It has a horizontal
circular hole of 30 mm diameter drilled centrally
thought it such that the axis of the hole cuts both
iagonally opposite vertical edges. Develop the lateral
surface of the prism, showing all construction lines. 20
http:tivww.knonline.in0.7, Draw the front views and top view of a square nut for a
24 mm bolt 20
Q8. Draw the three onbographic views of the Dovetail
Buide. 20