Professional Documents
Culture Documents
ASTM C 134-95 (Reapproved 1999)
ASTM C 134-95 (Reapproved 1999)
Copyright © ASTM, 100 Barr Harbor Drive, West Conshohocken, PA 19428-2959, United States.
--`-`-`,,`,,`,`,,`---
--`-`-`,,`,,`,`,,`---
--`-`-`,,`,,`,`,,`---
A—Width face
B—Thickness face
C—End face
FIG. 5 Method of Measuring Squareness
--`-`-`,,`,,`,`,,`---
Deviation Midpoint of Width
10 High Stack Oriented 29.83 0.02 0.04 0.04 0.1 0.05 0.12 0.14 0.35
10 High Stack Random 29.83 0.02 0.03 0.06 0.9 0.07 0.11 0.19 0.30
Bulk Density Pounds per 138.036 0.427 0.729 1.196 2.046 0.31 0.529 0.866 1.482
Cubic
Foot
using the same type of test equipment is given by the the true values of the properties of the reference material are
reproducibility interval and relative reproducibility interval not defined.
(coefficient of variation). The 95% reproducibility intervals are
given in Table 1. Two test results that do not differ by more 15. Keywords
than the reproducibility interval will be considered the same
and, conversely, two test results that do differ by more than the 15.1 bulk density; dimension; insulating firebrick; refracto-
reproducibility interval will be considered different. ries; size; squareness; warpage
14.2 Bias—No justifiable bias statement is possible since
The American Society for Testing and Materials takes no position respecting the validity of any patent rights asserted in connection
with any item mentioned in this standard. Users of this standard are expressly advised that determination of the validity of any such
patent rights, and the risk of infringement of such rights, are entirely their own responsibility.
This standard is subject to revision at any time by the responsible technical committee and must be reviewed every five years and
if not revised, either reapproved or withdrawn. Your comments are invited either for revision of this standard or for additional standards
and should be addressed to ASTM Headquarters. Your comments will receive careful consideration at a meeting of the responsible
technical committee, which you may attend. If you feel that your comments have not received a fair hearing you should make your
views known to the ASTM Committee on Standards, at the address shown below.
This standard is copyrighted by ASTM, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959, United States.
Individual reprints (single or multiple copies) of this standard may be obtained by contacting ASTM at the above address or at
610-832-9585 (phone), 610-832-9555 (fax), or service@astm.org (e-mail); or through the ASTM website (www.astm.org).